Preslaughter holding environment in pork plants is highly contaminated with Salmonella enterica.

The objective of this study was to determine whether abattoir pens can provide a Salmonella enterica infection source during the 2 to 4 h of preharvest holding. Previous work has suggested that pigs may be getting infected, but little has been reported on the environmental contamination of abattoir holding pens. For 24 groups of pigs studied ( approximately 150 animals/group) at two high-capacity abattoirs, six pooled fecal samples (n, 10 per pool) were collected from each transport trailer immediately after pigs were unloaded. Holding pens were sampled (one drinking water sample and six pooled floor samples consisting of swabs, residual liquid, and feces) prior to entry of study pigs for the routine holding period ( approximately 2.5 h). After slaughter, cecal contents and ileocecal lymph nodes were collected, on the processing line, from 30 pigs in each studied group. All samples were cultured for the isolation and identification of S. enterica by primary enrichment in GN-Hajna and tetrathionate broths, secondary enrichment in Rappaport-Vassiliadis broth, and plating on brilliant green sulfa and xylose-lysine-tergitol-4 agars, followed by biochemical and serological identification. The study pens were highly contaminated with S. enterica; all holding pens sampled had at least one positive sample. Additionally, 33% (8 of 24) of drinking water samples were positive for S. enterica. All 24 groups of pigs had S. enterica-positive cecal contents and ileocecal lymph nodes, including those groups from transport trailers with no positive samples. From pigs, trailers, and pens, 586 isolates representing 36 different Salmonella serovars were isolated. Of the 353 isolates from pigs (109 from ileocecal lymph nodes plus 244 from cecal contents), 19% were identified as belonging to the same serovars as those isolated from the respective pens; 27% were identified as belonging to the same serovars as those isolated from the trailers. Sixteen percent of the unique serovars were isolated from both pigs and pens, suggesting that pens served as the infection source. This study demonstrates highly contaminated abattoir holding pens and watering sources. It also demonstrates that holding pens can serve as an infection source. This study identifies the abattoir holding pens as a significant hazard and a potential control point for Salmonella contamination in the preharvest pork production chain.