Amino acid and energy digestibility in ten samples of distillers dried grain with solubles fed to growing pigs.

The objective of this experiment was to measure the digestibilities of energy, CP, and AA in 10 samples of corn distillers dried grain with solubles (DDGS) and in corn fed to growing pigs. Twelve growing barrows (initial BW: 34.0 +/- 1.41 kg) were allotted to an 8 x 12 Youden square design with 8 periods and 12 animals. Ten of 12 diets were based on the 10 DDGS samples (66.7%), 1 diet was based on corn (97%), and the last diet was a N-free diet based on cornstarch and sucrose. Chromic oxide (0.3%) was included in all diets as an inert marker. Pigs were provided their respective diets at a level of 3 times their estimated energy requirement for maintenance. The apparent (AID) and standardized (SID) ileal digestibilities for CP and AA were measured in the 10 samples of DDGS and in corn using the direct procedure, but the apparent total tract digestibilities for DM and GE were estimated using the difference procedure. The concentration of DE in each sample of DDGS and in corn was also calculated. The results of the experiment indicated variation among the different sources of DDGS in AID and SID for Lys, which ranged from 35.0 to 55.9% and 43.9 to 63.0%, respectively. For Met, the SID varied between 73.9 and 84.7%. However, the variability among samples in the SID for CP, and for the indispensable AA other than Lys and Met, was relatively low and ranged between 6 and 8 percentage units (i.e., from 64.0 to 70.6%, 74.1 to 80.1%, and 67.4 to 75.3% for Thr, Trp, and Ile, respectively). The SID for Trp in corn (72.8%) was lower (P < 0.05) than in DDGS, but for the remaining indispensable AA, except Arg, the SID for corn were greater (P < 0.01) than for DDGS. The DE concentration in the 10 samples of DDGS varied (P < 0.001) from 3,382 to 3,811 kcal of DE per kg of DM. For corn, the DE was 3,845 kcal per kg of DM. It is concluded that the AID and SID for Lys vary among samples of DDGS, but for most other AA the AID and SID are relatively similar and vary only 6 to 8 percentage units among different samples. Future work should focus on identifying the reasons for the variation in the digestibility of Lys to avoid processing procedures that are detrimental to Lys digestibility.