Lack of interactive effects between diet composition and acid addition with drying method on amino acid digestibility values in porcine ileal digesta.

Two experiments were conducted to determine the effect of oven drying (OD) or freeze drying (FD) on apparent ileal digestibility (AID) of AA in diets fed to pigs. In experiment 1, 15 barrows (88.4 ± 6.4 kg) were allotted to either a corn starch-soybean meal (CST), potato starch-soybean meal (PST), or corn-soybean meal (CSBM) diet, over 2 collection periods. Following collection, samples were pooled within pig and subdivided into either OD or FD, resulting in 10 observations per diet by drying-method combination. In experiment 2, 11 barrows (63.3 ± 3.8 kg) were fed a CST diet, and, following collection, samples were pooled within pig and subdivided and either adjusted to pH 4 or remain unadjusted. Subsets of these samples were then subdivided to be either FD or OD, resulting in 11 observations per pH level by drying-method combination. OD was accomplished by drying samples in a forced air oven at either 100 °C (experiment 1) or 75 °C (experiment 2). In experiment 1, there was no diet type by drying-method interactions noted for any of the AA (P > 0.10).OD resulted in a higher AID of AA compared with samples which were FD (P ≤ 0.10), for all AA except for Gly and Tyr. Averaged across all AA, AID of AA was 3.3% greater if the sample was OD compared with FD. Differences in AID of AA among the 3 diets were noted for all AA (P ≤ 0.07), except for Cys (P = 0.33), due to the fact that CST and PST diets only contained soybean meal (SBM) as an AA-providing ingredient while the CSBM diet contained both corn and SBM. Pigs fed the PST diet had greater SID for all AA compared with pigs fed the CST diet (P ≤ 0.05), except for His, Lys, Cys, and Glu. In experiment 2, there were no pH-adjustment by drying-method interactions noted on AID for any of the AA (P > 0.10). Adjusting ileal digesta to a pH of 4.0 had little effect on AID for most of the AA, except for a lowered AID of Arg, His, Lys, Trp, and Ser (P ≤ 0.10). OD resulted in a higher AID for all AA (P ≤ 0.09) except for Ile, Thr, Val, Ala, Asp, Glu, and Gly. Averaged across all AA, the increase in AID of AA was 1.7% greater if the sample was OD compared with FD. On average, OD of ileal digesta resulted in a 2.5% greater estimate of AID of AA compared with samples that were FD, and was not diet-, pH-, or AA-dependent. Because the majority of the data on AA digestibility are based on FD, a bias factor may be necessary to adjust AA digestibility data obtained on an OD-basis relative to an FD-basis for use in feed formulation. Published by Oxford University Press on behalf of the American Society of Animal Science 2020.