Effects of a novel corn-expressed E. coli phytase on digestibility of calcium and phosphorous, growth performance, and bone ash in young growing pigs1.

Two experiments were conducted to test the hypothesis that a corn-expressed phytase increases growth performance, bone measurements, and nutrient digestibility by young growing pigs, if added to diets that are deficient in Ca and P. In Exp. 1, 60 pigs (initial BW: 10.78 ± 0.67 kg) were randomly allotted to 6 dietary treatments that included a positive control diet (PC; 0.70% total Ca and 0.60% total P) and a negative control diet (NC; 0.50% total Ca and 0.42% total P). Four additional diets were formulated by supplementing the NC diet with 250, 500, 1,000, or 1,500 phytase units (FTU)/kg. Diets were fed for 28 d and the individual BW of pigs on days 1 and 28 were recorded. Fecal samples were collected from days 25 to 27 to calculate apparent total tract digestibility (ATTD) of Ca and P. On the last day of the experiment, all pigs were euthanized, and the left femur was removed and analyzed for ash, Ca, and P. Results indicated that growth performance, ATTD of Ca and P, and bone ash measurements were reduced (P < 0.05) in NC fed pigs compared with PC fed pigs. However, growth performance, ATTD of Ca and P, and bone ash measurements were improved (linear and quadratic, P < 0.05) by including increasing concentrations of phytase to the NC diet. In Exp. 2, experimental procedures were similar to those used in Exp. 1. Forty-eight pigs (initial BW: 11.15 ± 0.85 kg) were randomly allotted to 6 dietary treatments in a 28-d experiment. Treatments included a PC diet, an NC diet, and 4 diets in which 500 or 1,000 FTU/kg of either the corn-expressed phytase or a commercial microbial phytase were added to the NC diet. Pigs fed the NC diet had reduced (P < 0.01) final BW, ADG, G:F, and bone ash concentrations compared with pigs fed the PC diet. When 500 FTU/kg phytase was fed, no differences were observed in growth performance or bone ash measurements between phytase sources, and there were no differences in growth performance among pigs fed 1,000 FTU/kg of either phytase source or the PC diet. However, regardless of concentration or source of phytase, pigs fed the PC diet had greater (P < 0.001) amount of bone ash, bone Ca, and bone P compared with pigs fed phytase diets. In conclusion, the corn-expressed phytase is effective in improving growth performance, Ca and P digestibility, and bone measurements in pigs fed diets that are deficient in Ca and P.