Nutritive value of corn distiller's dried grains with solubles steeped without or with exogenous feed enzymes for 24 h and fed to growing pigs.

The use of corn distillers dried grains with solubles (DDGS) in pig diets is limited due to high fiber concentration. Steeping with exogenous fiber-degrading enzymes (FDE) may improve their feeding value. We evaluated apparent ileal digestibility (AID), standardized ileal digestibility (SID), and apparent total tract digestibility (ATTD) of components and DE content in DDGS steeped without or with two commercial FDE (A and B). Mixture of 350 g of DDGS, FDE (none for control), and 1.5 liters of water was incubated at 40 °C for 24 h with 15 min agitation every 40 min. FDE-A (pure combination) supplied 5,500 U of xylanase and 1,050 U of β-glucanase while FDE-B (multienzyme complex) supplied 1,200 U of xylanase, 150 U of β-glucanase, 500 U of cellulase, and 5,000 U of protease per kg of DDGS plus side activities. Samples were taken at time 0, 4, 8, and 24 h for organic acids and pH measurements. Three semi-purified corn starch-based diets were formulated with steeped DDGS as the sole source of CP. The basal mixture contained 0.2% TiO2 as indigestible marker. Six ileal-cannulated pigs (20 kg BW) were fed the three diets in a replicated 3 × 3 Latin square design to give six replicates per diet. Pigs were fed at 2.8× maintenance energy requirements and had free access to water. In each period, pigs were adjusted to diets for 7 d followed by 2 d for grab fecal and 2 d of 8 h continuous ileal digesta collection. There were no (P > 0.05) treatment and sampling time interaction or treatment effects on pH and lactic concentration. Lactic and acetic acids increased, and pH decreased (P < 0.05) over time points. The AID of CP, NDF, and crude fat and SID of CP were not different (P > 0.05) among treatments. Steeping DDGS with FDE-A had lower (P = 0.01) ATTD of NDF than control but higher (P = 0.001) ATTD of crude fat compared with the control or DDGS steeped with FDE-B. Values for DE content in steeped DDGS were not different (P > 0.05) and amounted to 4,095, 4,039, and 3,974 kcal/kg DM for the control, FDE-A, and FDE-B, respectively. In conclusion, under conditions of the study, steeping DDGS with exogenous enzymes did not improve fiber and energy digestibility.