Detection and characterization of Salmonella in lairage, on pig carcasses and intestines in five slaughterhouses.

In this study, conducted at five slaughterhouses, individual pigs were sampled and followed up from stunning to cooling down of the carcasses. In this way, Salmonella prevalence and possible risk points were described. At the lairage area, pens were sampled using overshoes. At stunning and bleeding, pigs were individually identified and subsequently swabs were taken of the oral cavity and the carcass after polishing, splitting and forced chilling. Additionally, duodenum, ileum, rectum and mesenteric lymph nodes were extracted and samples were taken of the scalding water. All samples were submitted to Salmonella isolation and Salmonella isolates were serotyped and genotyped by pulsed-field gel electrophoresis (PFGE). Of all samples taken (n = 1953), 14.1% were Salmonella positive. The prevalence of S. in the lairage area varied widely (from 0 to 100%) between the slaughterhouses. Of the sampled pigs (n = 226), 48.2% were positive in at least one sample. Statistical analysis revealed that the contamination of the lairage area was related to a higher amount of positive carcasses after polishing. Furthermore, the contamination of the carcasses after splitting and forced chilling was related to the contamination level of the carcass after polishing. A relation between the outer (carcass) contamination and the inner (gut content and lymph nodes) contamination of a pig could not be established. The predominant serotypes were S. Typhimurium (58.7%) and S. Derby (17.4%). Genotyping revealed 46 different PFGE profiles among the 276 Salmonella isolates. The same genotype at the lairage area as in the oral cavity of the pigs was found in 95%. The results indicate that the lairage area is a primary source of Salmonella in slaughter pigs and that carcass contamination originates from the environment rather than from the pig (inner contamination) itself. It further shows that slaughterhouses vary in their capability of dealing with Salmonella positive pigs. A slaughterhouse specific approach is needed, however, general guidelines should be provided to decrease the contamination level of the lairage area and the slaughter environment.