The outcome of extubation failure in a community hospital intensive care unit: a cohort study.

INTRODUCTION: Extubation failure has been associated with poor intensive care unit (ICU) and hospital outcomes in tertiary care medical centers. Given the large proportion of critical care delivered in the community setting, our purpose was to determine the impact of extubation failure on patient outcomes in a community hospital ICU.
METHODS: A retrospective cohort study was performed using data gathered in a 16-bed medical/surgical ICU in a community hospital. During 30 months, all patients with acute respiratory failure admitted to the ICU were included in the source population if they were mechanically ventilated by endotracheal tube for more than 12 hours. Extubation failure was defined as reinstitution of mechanical ventilation within 72 hours (n = 60), and the control cohort included patients who were successfully extubated at 72 hours (n = 93).
RESULTS: The primary outcome was total ICU length of stay after the initial extubation. Secondary outcomes were total hospital length of stay after the initial extubation, ICU mortality, hospital mortality, and total hospital cost. Patient groups were similar in terms of age, sex, and severity of illness, as assessed using admission Acute Physiology and Chronic Health Evaluation II score (P > 0.05). Both ICU (1.0 versus 10 days; P < 0.01) and hospital length of stay (6.0 versus 17 days; P < 0.01) after initial extubation were significantly longer in reintubated patients. ICU mortality was significantly higher in patients who failed extubation (odds ratio = 12.2, 95% confidence interval [CI] = 1.5-101; P < 0.05), but there was no significant difference in hospital mortality (odds ratio = 2.1, 95% CI = 0.8-5.4; P < 0.15). Total hospital costs (estimated from direct and indirect charges) were significantly increased by a mean of 33,926 US dollars (95% CI = 22,573 US dollars - 45,280 US dollars; P < 0.01).
CONCLUSION: Extubation failure in a community hospital is univariately associated with prolonged inpatient care and significantly increased cost. Corroborating data from tertiary care centers, these adverse outcomes highlight the importance of accurate predictors of extubation outcome.

Introduction

Approximately 10–15% of patients who are extubated from mechanical ventilation for acute respiratory failure require reintubation. Compared with patients who are successfully extubated, patients who are reintubated have worse clinical outcomes, including prolonged lengths of stay (LOSs) in the intensive care unit (ICU) and hospital, and increased mortality [1-4]. The cause for the increased mortality is not known but has been hypothesized to be either a delay in reintubation or a complication of the endotracheal intubation itself. Alternatively, extubation failure may simply be a marker of disease severity, comorbidities, or an unrecognized underlying disease process. When controlling for disease severity using multivariate analysis, recent studies [5,6] found extubation failure to be independently associated with hospital death, although this is not a uniform finding [7,8].

To date, the impact of extubation failure on patient outcomes has been studied exclusively in tertiary care, academic hospitals [1-9]. Because most inpatient care occurs in private, community medical centers, the true scope of the importance of extubation failure to patient outcome remains unknown. Moreover, the hospital costs associated with extubation failure have not been fully explored, having only been reported in postoperative vascular surgery patients [4]. The purpose of the present study was to determine the impact of extubation failure on ICU and hospital mortality, LOS, and total costs in a community hospital ICU.

Methods

Study population

The study was performed by reviewing medical records. The source population included all mechanically ventilated patients admitted to the medical/surgical ICU of a community hospital in Baltimore, Maryland, USA between January 1997 and June 1999 who met the following inclusion criteria: acute respiratory failure as a primary diagnosis; and mechanical ventilation for more than 12 hours. Patients were excluded if they were ventilated noninvasively by mask or via tracheostomy, if extubation occurred inadvertently (unplanned), or if they died or were transferred before extubation. All ICU patients were enrolled in the standardized hospital weaning protocol. Of those in the source population, all patients who failed extubation were included in the study cohort. Of those patients who were successfully extubated, an administrator blinded to the study hypothesis or patient data other than medical record number chose 100 unmatched patients to comprise the control cohort.

Standardized weaning protocol

Mechanical ventilation was discontinued under the direction of one of three board certified critical care physicians, respiratory therapists, and nursing staff. There was no pulmonary or critical care fellowship program in this ICU, and attending physicians provided off-site coverage at night from home.

A previously established hospital protocol to initiate the weaning process included requirements for hemodynamic stability, improvement in underlying medical conditions, reaching a threshold in three respiratory parameters (i.e. arterial oxygen tension/fractional inspired oxygen ratio >200, positive end-expiratory pressure ≤5 cmH2O, minute ventilation ≤12 l), and having a satisfactory cough. Patients were evaluated for these criteria as part of a daily screen performed by respiratory therapists. Spontaneous breathing trials were performed using a T-piece and were continued for up to 2 hours if patients maintained a heart rate under 120 beats/min, pulse oximetry greater than 93% and respiratory rate under 35 breaths/min, and had no dysrhythmia, paradoxic breathing, or use of accessory muscles. If spontaneous breathing trials were not tolerated after 2 days, then patients underwent weaning by gradual decrease in pressure support. Patients were considered for extubation if they tolerated T-piece or ventilatory support of no more than 5 cmH2O continuous positive airway pressure and pressure support of 8 cmH2O for 2 hours on fractional inspired oxygen under 50%. The decision to extubate was made by the intensivist on duty. Criteria for considering reintubation included, but were not limited to, the same criteria used to evaluate weaning trial tolerance.

Definition of variables

The primary exposure in this study was extubation failure, which was defined as reinstitution of mechanical ventilation within 72 hours of extubation. Successful extubation was defined as freedom from mechanical ventilation for 72 hours after extubation. The primary outcome was total ICU LOS (in days) after the initial extubation. Secondary outcomes were total hospital LOS (in days) after the initial extubation, ICU mortality, hospital mortality, and total hospital costs and costs per hospital day, which were estimated by abstracting total hospital charges from electronic billing records on all patients, including both direct and indirect charges. Total charges were divided by the institutional charge/cost ratio during the time period of review (1.21): hospital costs per day = (total hospital charges/total hospital length of stay)/1.21 Other outcome data recorded included ICU discharge disposition (step-down unit, floor, or died) and need for tracheostomy during hospitalization.

Demographic data

Demographic variables were also collected from existing medical records to describe patient groups further. Data obtained included age, sex, and severity of illness by Acute Physiology and Chronic Health Evaluation II score. Etiology of acute respiratory failure was classified as shown in Table 1. The surgical service was recorded as vascular, thoracic, gastrointestinal, orthopedic, or obstetric/gynecologic. Ventilator weaning data obtained included ICU days before the first weaning attempt, and total ventilator days before the first extubation attempt.

Table 1

Classification of etiology of acute respiratory failure

Classification	Details
Pulmonary	Upper airway obstruction, acute respiratory distress syndrome, chronic obstructuve pulmonary disease, lobar pneumonia, malignant effusion, aspergilloma, aspiration pneumonitis, lobar collapse, asthma exacerbation, noncardiogenic pulmonary edema
Cardiac	Congestive heart failure, pericarditis, primary cardiomyopathy, acute myocardial infarction, bacterial endocarditis
Neurologic	Status epilepticus, cerebral vascular accident, intracranial hemorrhage, convulsion/seizure disorder
Renal	Acute renal failure
Other	Liver failure, drug overdose, upper/lower gastrointestinal bleed, diabetic ketoacidosis, sepsis, blood transfusion reaction, vasculitis

Statistical analysis

Patients who were successfully extubated were compared with the group who failed extubation. Normality of outcome variables was assessed using the Shapiro Wilk test, and results are expressed as mean ± standard deviation or as median (interquartile range), as appropriate. Either the Student's two-tailed t-test or Wilcoxon rank sum test was used to compare the two groups, depending on normality. Odds ratios (ORs) were calculated using unadjusted logistic regression. Multivariate analysis was not performed because of the limited sample size. P < 0.05 was considered statistically significant. Statistical analyses were performed using NCSS, version 2000 (NCSS, Kaysville, UT, USA).

Results

Demographics

A total of 1451 mechanically ventilated patients were admitted from January 1997 until June 1999, and 315 patients met eligibility requirements for the study. The principal reason for study exclusion was mechanical ventilation not due to acute respiratory failure as the primary diagnostic category. Of those included, 252 patients were extubated successfully, and 93 of these with available medical records were included in the control group. Study cases were the 60 patients who failed extubation (Fig. 1). As shown in Table 2, patients were similar in terms of age, sex, severity of illness, and etiology of acute respiratory failure, derived from primarily pulmonary causes in both groups. Extubation failure was more common in surgical than in medical patients; of these the gastrointestinal and vascular services were more common in the failed extubation group. Study cases were reintubated a median of 24 hours after extubation.

Figure 1

Methodology for constructing the study.

Table 2

Patient demographics

Parameters	Total cohort	Successful extubation	Failed extubation
n	153	93	60
Age (years)	70 (60–78)	70 (60–77)	70 (59–79)
Male (n [%])	70 (45.8)	37 (39.7)	33 (55)
APACHE II score	21 (17–28)	21 (17–29)	21 (16–26)
Etiology of respiratory failure
Pulmonary	105 (68.6)	67 (72)	38 (63.3)
Cardiac	14 (9.2)	10 (10.8)	4 (6.7)
Neurologic	10 (6.5	5 (5.4)	5 (8.3)
Renal	2 (1.3)	2 (2.2)	0 (0)
Other	16 (10.5)	6 (6.5)	10 (16.7)
Surgical service	32 (20.9)	10 (10.8)	22 (36.7)
Gastrointestinal	15 (9.8)	3 (3.2)	12 (20.0)
Vascular	8 (5.3)	2 (2.2)	6 (10.0)
Thoracic	6 (6.9)	2 (2.2)	4 (6.7)
Obstetric/gynecologic	1 (0.6)	1 (1.1)	0 (0.0)
Days before initiation of weaning	1 (0.5–2)	1.25 (1–2.4)	1 (0.5–2)
Pre-extubation (days)	3 (1–7)	4 (2–7)	2 (1–5)

Data presented as median (interquartile range) or as n (%). APACHE, Acute Physiology and Chronic Health Evaluation.

Outcomes of respiratory failure

As shown in Table 3, failed extubation was associated with a significant increase in the ICU and hospital LOSs following the initial extubation event (P < 0.01 for both); however, total hospital days after ICU discharge were not significantly different between groups. Reintubated patients were more likely to be transferred to a step-down unit, and less likely to be discharged directly to hospital floors. Total charges for hospitalization and cost per day were significantly increased for patients who failed extubation (P < 0.01). A higher proportion of patients who failed extubation expired in the ICU (OR = 12.2, 95% confidence interval = 1.5–101; P < 0.05), although hospital mortality of reintubated patients did not reach statistical significance (OR = 2.1, 95% confidence interval = 0.8–5.4; P > 0.05). As shown in Table 4, the poor outcome following failed extubation was consistent in both subgroups of medical and surgical patients.

Table 3

Patient outcomes

Parameters	Successful extubation	Failed extubation	P
ICU LOS postextubation (days)	1 (0.3–2)	10 (7–15)	<0.01
ICU discharge disposition
Step-down unit	40 (43)	35 (58.3)	0.070
Floor	48 (51.6)	13 (21.7)	<0.01
Died in ICU	1 (1.1)	7 (11.7)	<0.01
Post-ICU LOS (days)	8.3 ± 7.3	11.2 ± 10.7	0.070
Hospital LOS postextubation (days)	6 (4–11)	17 (12–23)	<0.01
Hospital mortality	9 (9.7)	11 (18.3)	0.144
Total hospital charges (×US$1000)	23 (15–34)	48 (34–76)	<0.01
Cost per hospital day (×US$1000)	1.7 ± 0.5	2.0± 0.4	<0.01
Tracheostomy	7 (7.5)	7 (11.7)	0.402
Total mechanical ventilation (days)	4 (2–8)	10 (6–16)	<0.01

Data are presented as mean ± standard deviation, median (interquartile range), or n (%). ICU, intensive care unit; LOS, length of stay.

Table 4

Patient outcomes in surgical and medical subsets

Outcomes	Medical			Surgical
	Successful extubation	Failed extubation	P	Successful extubation	Failed extubation	P
n	83	38		10	22
ICU LOS postextubation (days)	1 (0–1)	8 (5–15)	<0.01	2 (1–4)	12 (9–17)	<0.01
Hospital LOS postextubation (days)	5 (3–10)	15 (11–19)	<0.01	6 (9–14)	18 (16–29)	<0.01
Hospital mortality (%)	8 (9.6)	5 (13.2)	0.560	1 (10)	6 (27.3)	0.230
Total hospital charges (×US$1000)	26.5 ± 17.0	49.7 ± 30.0	<0.01	26.8 ± 9.0	81.6 ± 47	<0.01

Data are presented as mean ± standard deviation, median (interquartile range) or n (%). ICU, intensive care unit; LOS, length of stay.

Discussion

This study demonstrates that failed extubation had an adverse impact on clinical outcomes in patients recovering from acute respiratory failure in a community hospital ICU. We found that reintubation increased ICU and hospital LOSs, as well as total hospital costs and cost per hospital day.

In the whole cohort and both medical and surgical subgroups, failed extubation was associated with increased LOS in both the ICU and hospital after the initial extubation (Tables 3 and 4). These findings corroborate data obtained in ICUs at tertiary care centers, and contribute to the available literature by demonstrating the importance of reintubation in the community hospital setting. In an exclusively medical ICU, Epstein and coworkers [6] found that extubation failure prolonged ICU stay by 17 days after initial extubation, which is greater than the additional 9 days identified in the present study. Similar to our data, Dupont and coworkers [8] showed that reintubation increased ICU LOS by 9 days in an exclusively surgical population. Variations in postextubation failure LOS between populations are known to correlate with the etiology of extubation failure [9], with worse outcomes associated with nonairway etiologies. In addition, complications associated with the process of reintubation, such as ventilator-associated pneumonia, may contribute to the need for prolonged intensive care [10]. These factors were not documented during our review and this is a limitation of our analysis. Failed extubation did not increase post-ICU discharge LOS in this study, despite the increased frequency of transfer to a step-down unit (Table 3); this may be explained by the increased ICU mortality found in reintubated patients.

We found that the increased duration of patient care after failed extubation doubled the total hospital costs and costs per day, as compared with patients who did not require reintubation (Table 3). An analysis of the specific constituents that account for this increase in total costs, such as pharmacy, staff, laboratory, or facility expenses, was beyond the scope of the present study. Our findings in a medical/surgical ICU, however, extend the data presented by Pronovost and coworkers [4] from a cohort of vascular surgery patients who failed extubation. They found that reintubation resulted in a 20% increase in hospital charges. Both reports present hospital charges as a surrogate for hospital costs, which may not be an accurate reflection of actual cost [11].

ICU mortality was significantly higher in patients who failed extubation. This is consistent with the findings of Epstein and Ciubotaru [9], who also reported that sepsis and multiorgan failure were the more common causes of mortality following reintubation. We did not find an association between extubation failure and hospital mortality in our community hospital setting, probably because of limited sample size. This contrasts with findings reported in prior studies performed in some tertiary care centers [5,6], but is similar to the findings of others [7,8]. In addition, our hospital mortality rates (Table 3) are substantially lower than those reported by Epstein [6] and Esteban [5], which may account for the lack of association between extubation failure and hospital death. The reason for the comparatively higher survival rate of medical patients in our hospital is not clear, but it may be due differences in the etiology or timing of reintubation, because these factors have been shown to have an important influence on patient outcomes [6,9]. Alternatively, severity of illness or perhaps some unrecognized aspect of the delivery of patient care, which may differ in the community hospital setting, may also account for these findings.

Conclusion

We have demonstrated that extubation failure may be an important ICU complication because of its association with adverse patient outcomes and cost in a community hospital. Through univariate analysis, we corroborated the unfavorable consequences of reintubation, such as increased ICU and hospital LOSs, that were previously reported in tertiary care academic hospitals. Our findings underscore the need for further study of predictive indices of extubation outcome that may help to prevent the substantial morbidity associated with reintubation.

Key messages

• Failed extubation is associated with adverse patient outcomes in a community hospital.

• Reintubation increased ICU mortality, hospital cost, and ICU and hospital LOSs after extubation.

• These findings are consistent with the poor outcome following failed extubation in tertiary care centers.

Competing interests

None declared.

Abbreviations

ICU = intensive care unit; LOS = length of stay; OR = odds ratio.