Kinetics of whole serum and prepurified IgG digestion by pepsin for F(ab')2 manufacture.

An alternative route for the production of polyclonal F(ab')(2) fragments that might be adopted for the facile preparation of antivenoms is assessed in this work. The method involves the digestion of whole serum by free pepsin, which results in reduction of the number of processing steps commonly in use, because it avoids the initial purification of IgG's prior to their proteolytic cleavage by the enzyme. Digestion kinetics of whole serum and caprylic acid prepurified IgG using free pepsin were monitored with SDS-PAGE followed by densitometric analysis and antigen binding activity assay of the digested samples. It was observed that with equal units of pepsin activity, caprylic acid prepurified IgG was digested more rapidly than whole serum but that the overall retention of antigen binding activity was significantly greater in the latter case. The estimated first-order digestion rate parameters were 11.8 and 4.42 microM min(-)(1) for pure IgG and whole serum, respectively. The K(m) value obtained for whole serum digestion was 33 microM and that for pure IgG digestion was 43.5 microM. Calibration with undigested whole serum and pure IgG samples of known concentrations was performed using SDS-PAGE followed by image analysis. A linear relationship was observed between the protein concentration and the respective band intensity within the range of concentrations investigated (0.63-31.2 microM IgG concentration). This technique proved to be relatively rapid, reproducible, and more precise than size-exclusion chromatography as a result of its F(ab')(2)/IgG resolving power. Staining and destaining protocols were reproduced in terms of staining and destaining times, volumes added, and compositions. Furthermore, all digestion experiments were performed in duplicate sets to monitor the extent of variation of the digestion kinetic parameters measured by this method. The results obtained from this technique confirm and quantify previous observations that pepsin digestion of whole serum is slower and easier to control than digestion of pure IgG and results in higher recovery of antigenic binding activity.