Assessment of butadiene exposure in synthetic rubber manufacturing workers in Texas using frequencies of hprt mutant lymphocytes as a biomarker.

1,3-Butadiene (BD), which is used to manufacture synthetic rubber, is a mutagen and carcinogen. Because past occupational exposures have been associated with an increased risk of leukemia, there has been a dramatic reduction in workplace exposure standards. The health benefits of these reduced levels of occupational exposure to BD will be difficult to evaluate using relatively insensitive traditional epidemiological studies; however, biomarkers can be used to determine whether there are genotoxic effects associated with recent exposures to BD. In past studies of BD-exposed workers in Southeast Texas, we observed an increase in the frequency of lymphocytes with mutations in a reporter gene, hprt. Frequencies of hprt mutant cells correlated with air levels of BD and with the concentration of a BD metabolite in urine. Average exposures to 1-3 parts per million (p.p.m.) of BD were associated with a threefold increase in hprt variant (mutant) frequencies (Vfs). We now report results from a follow-up study of workers in a synthetic rubber plant in Southeast Texas. Thirty-seven workers were evaluated on three occasions over a 2-week period for exposure to BD by the use of personal organic vapor monitors and by determining the concentration of a BD metabolite in urine. The frequency of hprt mutants was determined, by autoradiography, with lymphocyte samples collected 2 weeks after the final exposure measurement. Based on their work locations, the study participants were assigned to high-exposure (N=22) or low-exposure (N=15) groups. The BD exposure, +/-standard error, of the workers in the high-exposure group (1.65+/-0.52 p.p.m.) was significantly greater than the low-exposure group (0.07+/-0.03 p.p.m.; P<0.01). The frequency of hprt mutant lymphocytes was also significantly different in the two groups (high, 10.67+/-1.5 x 10(-6); low, 3.54+/-0.6 x 10(-6); P<0.001). The concentration of the urine metabolite was greater in the high-exposure group, but the difference was not significant. The correlation coefficient between hprt Vf and BD exposure levels was r=0.44 (CI(95), 0.11-0.69; P=0.011). This study reproduced the findings from a previous study at this plant. Although studies of butadiene-exposed workers in other countries have not detected an effect of exposure on frequencies of hprt mutant lymphocytes, we have repeatedly observed this result in our studies in Texas.