Transforming waste activated sludge into medium chain fatty acids in continuous two-stage anaerobic fermentation: Demonstration at different pH levels.

Bioenergy recovery in the form of medium-chain fatty acids (MCFAs) from waste activated sludge (WAS) is increasingly attractive, which are valuable building blocks for fuel production. This study experimentally demonstrated the long-term MCFAs (C6-C8) production from WAS in two-stage anaerobic sludge fermentation at different pH conditions, using continuously operated bench-scale anaerobic reactors. The WAS was continuously converted to short chain fatty acids (SCFAs, 3500-3800 mg chemical oxygen demand (COD)/L) at the first stage via alkaline anaerobic fermentation, which was directly fed into the second stage as both substrates and inoculum for MCFAs production through chain elongation (CE). The productions of MCFAs at the second stage were continuously studied under three different pH conditions (i.e., 10, 7 and 5.5). The results demonstrated that there was no significant MCFAs production at pH 10 during the steady state, whereas the MCFAs productions were clearly observed at both pH 7 and pH 5.5, with much higher MCFAs production from WAS at pH 7 (i.e., 10.32 g COD/L MCFAs) than that at pH 5.5 (i.e., 8.73 g COD/L MCFAs) during the steady state. A higher MCFAs selectivity of 62.3% was also achieved at pH 7. The relatively lower MCFAs production and selectivity at pH 5.5 was likely due to the higher undissociated MCFAs generated at pH 5.5, which would pose toxicity impact on CE microbes and thus inhibit the CE process. Microbial community analysis confirmed that the relative abundances of CE related microbes (e.g., Clostridium sensu stricto 12 sp. and Clostridium sensu stricto 1) increased at pH 7 compared to those at pH 5.5, which enabled more efficient MCFAs production from WAS.