OBJECTIVE: Investigation of defensive reactions, piglet losses, post-bleeding and recovery time of suckling piglets castrated under automated isoflurane anesthesia as well as measurements of isoflurane concentrations in ambient air and estimation of the cleaning and disinfection success of anesthesia masks. MATERIAL AND METHODS: A total of 955 suckling piglets (age: 4.0 ± 1.2 days; weight: 2.0 ± 0.5 kg) were castrated under automated isoflurane anesthesia (PorcAnest 3000®) after the administration of a non-steroidal anti-inflammatory drug. Reactions during the procedure were assessed before castration using the interdigital claw reflex and during castration by defensive movements and vocal response. The piglets' recovery time was evaluated in the stable corridor (pass 1) and the farrowing pen (passes 4-5). In 73 animals, the spermatic cord was cut with a scalpel and the post-operative bleeding visually evaluated. In addition, exposure measurements of isoflurane were performed and anesthetic masks were examined for total bacterial contamination and indicator bacteria before and after the anesthetic procedure and following their disinfection. RESULTS: Following insufflation of isoflurane for 90 seconds 94.3 % of the piglets and after prior testing of the interdigital claw reflex and possible extension of the anesthetic supply 95.3 % of the piglets showed no or minimal defensive movements during castration. An anesthetic incident occurred in 0.9 % of the piglets, but no animal died. The recovery time lasted 7.3 ± 4.7 minutes (pass 1) and 6.2 ± 3.3 minutes (passes 4-5). Cutting the spermatic cord with a scalpel led to a higher post-bleeding score (p < 0.001) compared to use of the emasculator. Isoflurane concentrations in ambient air ranged between 4.5 und 28.1 mg/m3. Masks disinfection reduced the total germ count by 99.8 %. Contaminations with Escherichia coli and MRSA were no longer detectable in 4 of 6 cases after disinfection. CONCLUSION: Isoflurane anesthesia led in over 94 % of the piglets to no or minimal defensive reactions during castration. Anesthetic incidents occurred rarely and no piglet losses were recorded. Therefore, automated isoflurane anesthesia is associated with a low risk for suckling piglets. Measurements of isoflurane concentrations on persons involved were below the internationally lowest limit value. Disinfection of the anesthesia masks may prevent germ transmission between animal groups via this potential vector. Thieme. All rights reserved.
OBJECTIVE: Investigation of defensive reactions, piglet losses, post-bleeding and recovery time of suckling piglets castrated under automated isoflurane anesthesia as well as measurements of isoflurane concentrations in ambient air and estimation of the cleaning and disinfection success of anesthesia masks. MATERIAL AND METHODS: A total of 955 suckling piglets (age: 4.0 ± 1.2 days; weight: 2.0 ± 0.5 kg) were castrated under automated isoflurane anesthesia (PorcAnest 3000®) after the administration of a non-steroidal anti-inflammatory drug. Reactions during the procedure were assessed before castration using the interdigital claw reflex and during castration by defensive movements and vocal response. The piglets' recovery time was evaluated in the stable corridor (pass 1) and the farrowing pen (passes 4-5). In 73 animals, the spermatic cord was cut with a scalpel and the post-operative bleeding visually evaluated. In addition, exposure measurements of isoflurane were performed and anesthetic masks were examined for total bacterial contamination and indicator bacteria before and after the anesthetic procedure and following their disinfection. RESULTS: Following insufflation of isoflurane for 90 seconds 94.3 % of the piglets and after prior testing of the interdigital claw reflex and possible extension of the anesthetic supply 95.3 % of the piglets showed no or minimal defensive movements during castration. An anesthetic incident occurred in 0.9 % of the piglets, but no animal died. The recovery time lasted 7.3 ± 4.7 minutes (pass 1) and 6.2 ± 3.3 minutes (passes 4-5). Cutting the spermatic cord with a scalpel led to a higher post-bleeding score (p < 0.001) compared to use of the emasculator. Isoflurane concentrations in ambient air ranged between 4.5 und 28.1 mg/m3. Masks disinfection reduced the total germ count by 99.8 %. Contaminations with Escherichia coli and MRSA were no longer detectable in 4 of 6 cases after disinfection. CONCLUSION: Isoflurane anesthesia led in over 94 % of the piglets to no or minimal defensive reactions during castration. Anesthetic incidents occurred rarely and no piglet losses were recorded. Therefore, automated isoflurane anesthesia is associated with a low risk for suckling piglets. Measurements of isoflurane concentrations on persons involved were below the internationally lowest limit value. Disinfection of the anesthesia masks may prevent germ transmission between animal groups via this potential vector. Thieme. All rights reserved.