Bovine surfactant in the treatment of pneumonia-induced-neonatal acute respiratory distress syndrome (NARDS) in neonates beyond 34 weeks of gestation: a multicentre, randomized, assessor-blinded, placebo-controlled trial.

Neonatal acute respiratory distress syndrome (NARDS) reflects pulmonary surfactant dysfunction, and the usage of bovine surfactant (Calsurf) supplement may therefore be beneficial. To determine whether bovine surfactant given in NARDS can improve oxygenation and survival rate, we conducted a multicenter, randomized trial between January 2018 and June 2019, and we compared Calsurf treatment to controls in neonates with pneumonia accompanied by NARDS. Neonates who met the Montreux criteria definition of NARDS were included, and those with congenital heart and lung malformations were excluded. Primary outcomes were oxygenation index (OI) after Calsurf administration, and secondary outcomes were mortality, and duration of ventilator and oxygen between the two groups, and also other morbidities. Cumulatively, 328 neonates were recruited and analyzed, 162 in the control group, and 166 in the Calsurf group. The results shows that OI in the Calsurf group were significantly lower than that in the control group at 4 h (7.2 ± 2.7 and 11.4 ± 9.1, P = 0.001); similarly, OI in the Calsurf group were significantly lower than in the control group at 12 h ( 7.5 ± 3.1 and 11.2 ± 9.2, P = 0.001). Mortality and duration of ventilator support or oxygen use between the two groups were not significantly different.
Conclusion: Calsurf acutely improved OI immediately after administration in pneumonia-induced NARDS; although, we observed no significant decrease in mortality, duration of ventilator or oxygen, or major morbidity. What is known: • The definition proposed as the Monteux criteria for neonatal acute respiratory distress syndrome (NARDS). • Surfactant acutely improved oxygenation and significantly decreased mortality in children and adolescents with acute lung injury. What is new: • This is the first large randomized controlled trail to study on surfactant treatment of neonates with acute respiratory distress syndromes. • Surfactant acutely improved oxygenation immediately after administration in pneumonia-induced NARDS at a gestational age beyond 34 weeks.

RCT Entities:   Population Interventions Outcomes

Introduction

In 2015, the Pediatric Acute Lung Injury (ALI) Consensus Conference 2015 (PALICC) developed diagnostic criteria for acute respiratory distress syndrome (ARDS) in children ranging from infants to teenagers. ARDS is a generalized inflammatory response of the lung to catastrophic events of various pulmonary and non-pulmonary origins, such that children with ARDS often exhibit high mortality [1]. It is generally accepted that the degree of hypoxemia predicts outcome, mortality in children with a PaO2/FiO2 ratio lower than 100 greater than 50%. Another outcome predictor is ventilation support, reflected in mean airway pressure [2]. There are many ventilation strategies being evaluated in the pediatric age group to prevent barotrauma and volutrauma, including high-frequency oscillatory ventilation (HFV), inhaled nitric oxide, extracorporeal membrane oxygenation (ECMO), and surfactant treatment [3].

In 2017, De Luca et al. [4] proposed the Monteux definition for neonatal acute respiratory distress syndrome (NARDS). But information regarding NARDS—especially treatment strategies—is still limited. Chinese clinicians performed several single-center clinical studies that were published in Chinese journals [16, 17], finding that Calsurf (Shuanghe Pharmaceutics, Beijing, China) supplement benefited infants with NARDS. However, to our knowledge, there is still paucity of evidence from randomized controlled trials to support the application of surfactant in NARDS. Thus, we performed a randomized, multicenter, assessor-blinded, placebo-controlled trial in patients with NARDS induced by pneumonia to better understand whether oxygenation and survival rate improve after exogenous surfactant administration in cases of mild, moderate, and severe NARDS.

Methods

Patients

The present study was a randomized control trial (ChiCTR-OPC-17011351) conducted at 12 level 3 neonatal intensive care units between January 2018 and June 2019. The distribution of the 12 centers is depicted in Supplementary Data, and the study protocol was approved by the review boards of these institutes. Informed consent was obtained from a parent or guardian before enrollment.

Entry criteria included (1) a gestational age above 34 weeks and (2) an acute onset of pneumonia no later than 1 week of age. The definition of neonates pneumonia was according to Dell’Orto’s report: presented respiratory distress with either patchy infiltrates and/or irregular opacities at chest radiogram or loss of aeration/consolidations on lung ultrasound and both of the following criteria: (1) at least one of the following: risk factors for perinatal infection (chorioamnionitis, maternal fever, bacterial colonization, rupture of membranes for more than 18 h); (2) at least one of the following: serum C-reactive protein >10 mg/L, or serum procalcitonin beyond reference values according to hours of life[24]; (3) absence of congenital heart disease that would explain the edema (such as ductus arteriosus with pulmonary overflow if no acute pulmonary hemorrhage existed–echocardiography was needed to verify the origin of the edema); (4) oxygenation deficit expressed as OI, mild NARDS at 4–7.9 , moderate NARDS at 8–15.9, and severe NARDS at ≥ 16. Exclusion criteria included RDS, TTN, or any congenital anomaly capable of causing a primary, current, acute respiratory condition. These inclusion and exclusion criteria depict a newborn population completely fulfilling the Montreux criteria for the diagnosis of NARDS [4].

Grouping and randomization

Neonates were assigned randomly to control or Calsurf groups: random numbers were generated by a computer program and randomization performed using serially numbered, opaque, sealed envelopes that were opened by research personnel after obtaining parental consent. According to protocol, a second intervention was performed 12 h later if the oxygenation index remained higher than 7.

Although blinding of the clinicians was not possible due to the nature of the intervention, assessors who did data collection and measured OI were blinded to the type of treatment administered.

Methods of surfactant administration

Calsurf is extracted from lung lavage of calves. Total phosphate lipids are 35 mg/ml, with 59% of DPPC; 0.78 mg/m l of surfactant B and 1.74 mg/ml of surfactant C. The recommended dosage is 100 mg/kg.

For surfactant administration, the position of the endotracheal tube was determined by the length of the tube at the lip, the symmetry of breath sounds, and the symmetric rising of the chest wall. Natural surfactant (Calsurf; Shuanghe Pharmaceutics, China) was refrigerated at − 10 °C before use and solubilized in 1.5 mL of sterile water to form a suspension. The suspension was warmed to approximately 37 °C and then a catheter was used to administer the surfactant near the proximal end of the endotracheal at a dose of 100 mg/kg. The infants were disconnected with the tube and manual bag positive pressure ventilation (maintained for approximately 5 min) was exerted during surfactant administration, followed by mechanical ventilation. The control group received a volume equivalent air bolus in the endotracheal tube, followed by manual bag positive pressure ventilation (maintained for approximately 5 min).

Study outcomes

Primary outcomes were OI at 4, 12, and 24 h after administration of Calsurf. OI was based on pre-ductal arterial PaO2 in all infants included. Secondary outcomes were mortality, duration of ventilator or oxygen, and major morbidity issues, including incidence of pneumothorax, pulmonary hypertension, stage 2 or greater necrotizing enterocolitis (NEC), grade 3/4 intracranial ventricular hemorrhage (IVH), or periventricular leukomalacia (PVL).

We conducted a stratified study, and OI and mortality were compared between pre-specified subgroups.

Small-for-gestational-age (SGA) was defined as birth weight below the 10th percentile at a particular gestational week in Fenton growth chart [5].

Sample size calculation and statistical analysis

The preliminary data from our center indicated that the OI was 11 in controls, and we hypothesized that treatment would decrease OI to 7. We therefore required 130 cases and 130 controls to be able to reject the null hypothesis that the exposure rates for cases and controls were equal, with a probability (power) 0.8. The type I error probability associated with the test of our null hypothesis was 0.05. We anticipated an attrition of 10% of infants, and therefore needed to enroll 145 patients were needed in each group.

We used the statistical software packages SPSS for Windows version 19 for data analyses. Continuously distributed variables were expressed as mean ± one standard deviation, and categorical variables were summarized as numbers and percentages. We used analysis of variance (ANOVA) after analyzing for homogeneity analysis of variance, and this was followed by post hoc testing. The nonparametric rank-sum test (Kruskal–Wallis test) was used if the variance was not homogenous. We performed a multivariate linear regression analysis to rule out confounding factors. Candidate variables with a p value < 0.1 on univariate analysis and considered clinically relevant were included in multivariable model. Variables for inclusion were carefully chosen, given the number of events available. All the eligible variables were entered into the model. Results are presented as beta and confidence intervals (CI 95%) and p values. Adjusted R2 is presented to evaluate the goodness of fit evaluation. P < 0.05 was considered to show a significant difference.

Results

Baseline characteristics and antenatal factors of the two groups

A total of 345 neonates met the inclusion criteria and provided consent: 172 of these neonates were randomly assigned to the control group and 173 were randomly assigned to the Calsurf treatment group. Ten infants died in the control group and seven infants died in the Calsurf group, and therefore 162 controls and 166 treatments were ultimately analyzed (Fig. 1). Baseline characters and antenatal factors of the two groups were similar, although P values for prenatal steroid usage and gestational age showed a tendency toward significance (Table 1). In the Calsurf treatment group, patients received an average of 3 doses (1 to 8) of surfactant.

Fig. 1

Flow chart of the participants

Table 1

Baseline characteristics and antenatal factors of the two groups

	Control (n = 162)	Calsurf treatment (n = 166)	Univariate analysis (P)
Gestational age (weeks), mean (SD)	37.86 (2.6)	37.34 (2.1)	0.07
Birth weight (g), mean (SD)	3090 (503)	2985 (579)	0.08
Male, N (%)	101 (62)	108 (65)	0.61
Cesarean section, N (%)	114 (70)	124 (75)	0.38
Apgar score at 5 min, mean (SD)	8 (1.6)	8 (1.3)	0.12
Antenatal steroid, N (%)	13 (8)	23 (14)	0.09
Pregnancy-induced maternal disease, N (%)	40 (25)	45 (27)	0.91
PPROM, N (%)	25 (15)	30 (18)	0.71
Postnatal hours of NARDS recruitment, mean (SD)	42.3 (50.5)	44.7 (52.1)	0.86
OI at study entry	15.5 (11.7)	14.9 (11.5)	0.71
Small for gestational age, N (%)	5 (3.1)	7 (4.2)	0.45

PPRPM, prolonged premature rupture of membrane. Values are number (percentage) unless otherwise indicated. P > 0.05 for all comparisons

Primary outcome

The results between-group patients comparisons shows that OI in the Calsurf group were significantly lower than in the control group at 4 h (7.2 ± 2.7 and 11.4 ± 9.1, P = 0.001), similarly, OI in the Calsurf group were significantly lower than in the control group at 12 h (7.5 ± 3.1 and 11.2 ± 9.2, P = 0.001) (Fig. 2).

Fig. 2

Oxygen index in mild, moderate and severe NARDS. a mild NARDS; b moderate NARDS; c severe NARDS; d total. The overall p value for within patients comparisons: in Calsurf treatment group, OI decreased significantly after 4 h surfactant given (7.23 ± 2.73 at 4 h, 14.89 ± 11.44 at 0 h, P < 0.001) and 12 h given (7.53 ± 3.13 at 12 h, 14.89 ± 11.44 at 0 h, P < 0.001), while the same change pattern can be seen in control group, although the decline is not as obvious as control group. The between-group patients’ comparisons: Calsurf administration significantly decreased the OI in mild, moderate, and severe cases of NARDS, especially moderate and severe cases. Data shown are mean values; error bars indicate SEM. *P < 0.05for the significant difference between groups

We conducted a stratified study, and the results are shown in Fig. 2. Infants with NARDS were stratified into three categories according to oxygenation deficit expressed as OI: mild NARDS, 4–7.9; moderate NARDS, 8–15.9; and severe NARDS, ≥ 16. The cases of mild, moderate, and severe NARDS in this study were 105, 113, and 110, respectively, and Calsurf administration significantly decreased the OI in all 3 groups, especially in moderate and severe cases (Fig. 2). We performed a multivariate linear regression analysis of OI at 4 and 12 h using subgroup partitioning, and the results are presented in Table 2. When we brought the variables (prenatal steroids, gestational age, and intervention) into the regression model to remove the confounding factors, we observed that only Calsurf treatment was a dependent protective factor in reducing OI.

Table 2

Multivariate linear regression analysis of OI at 4, 12 h

	Mild NARDS				Moderate NARDS				Severe NARDS
	Beta	95% CI	P	Adj. R2	Beta	95% CI	P	Adj. R2	Beta	95% CI	P	Adj. R2
4 h				0.06				0.37				0.65
Gestational age	0.05	− 0.02,0.1	0.1		− 0.1	− 0.25,0.0	0.0		− 0.03	− 0.54,0.48	0.91
Antenatal steroid	0.17	− 0.38, 0.71	0.54		0.06	− 1.45, 1.57	0.94		2.02	− 1.42, 5.46	0.25
Calsurf	− 0.46	− 0.79, − 0.12	0.01		− 2.49	− 3.11, − 1.88	0.00		− 15.8	− 18.03, − 13.59	0.0
12 h				0.04				0.12				0.59
Gestational age	0.03	− 0.6,0.13	0.48		− 0.12	− 0.27,0.04	0.13		0.00	− 0.52,0.53	0.99
Antenatal steroid	0.22	− 0.47, 0.92	0.52		− 0.44	− 2.15, 1.26	0.61		1.98	− 1.54,5.49	0.27
Calsurf	0.54	0.11–0.97	0.02		− 1.44	− 2.13, − 0.75	0.0		− 14.3	− 16.6, − 12.06	0.0

Secondary outcomes

The overall mortality rate in NARDS was approximately 5%, with 10 deaths in control group and 7 deaths in Calsurf group. Duration of ventilation or oxygen and length of hospital stay did not differ between the two groups (P > 0.05), and we did not observe a difference in the incidence of pneumothorax, pulmonary hypertension, NEC (stage 2 or greater), grade 3/4 IVH, or PVL (Table 3).

Table 3

Secondary outcomes in the two groups

Secondary outcomes	Control (n = 162)	Calsurf treatment (n = 166)	Univariate analysis (P)	Multivariate analysis
				Confounders	Beta	95% CI	P
Hours on mechanical ventilator, mean (SD)	92.1 (42.8)	88.8 (71.1)	0.625	Gestational age	− 0.190	− 2.819, 2.438	.887
				Antenatal steroid	− 28.768	− 48.911,− 8.625	.005
				Calsurf	− 1.773	− 13.939, 10.392	.774
Ventilator free days, mean (SD)	8.8 (4.9)	10.1 (6.7)	0.163	Gestational age	0.008	− .102, .117	.887
				Antenatal steroid	1.199	.359, 2.038	.005
				Calsurf	0.074	− .433, .581	.774
Hours on oxygen (hours), mean (SD)	192 (105)	193 (99)	0.862	Gestational age	0.502	− 4.251, 5.254	.836
				Antenatal steroid	− 31.261	− 67.681, 5.160	.092
				Calsurf	4.485	− 17.511, 26.481	.689
Length of stay (days), mean (SD)	15.1 (7.3)	14.9 (6.1)	0.834	Gestational age	− 0.070	− .387, .246	.663
				Antenatal steroid	1.669	− .758, 4.097	.177
				Calsurf	− 0.196	− 1.664, 1.272	.793
Pneumothorax, n (%)	28 (17.3)	25 (15.1)	0.501	Gestational age	1.048	.921, 1.191	.479
				Antenatal steroid	0.359	.113, 1.387	.147
				Calsurf	0.825	.454, 1.500	.529
Grade 3/4 IVH and/or PVL, n (%)	15 (9.2)	9 (5.4)	0.153	Gestational age	1.026	.859, 1.226	.776
				Antenatal steroid	0.724	.154, 3.417	.684
				Calsurf	0.539	.227, 1.278	.161
Pumonary Hypertension, n (%)	9 (5.6)	6 (3.6)	0.380	Gestational age	0.839	.658, 1.071	.158
				Antenatal steroid	1.969	.383, 10.112	.417
				Calsurf	0681	.231, 2.010	.487
Necrotizing enterocolitis stage 2 or higher, n (%)	1 (0.6)	0 (0)	0.306	Gestational age	− 1.305	.007, 10.340	.482
				Antenatal steroid	16.194	.000	.998
				Calsurf	15.111	.000	.996

IVH, intraventricular hemorrhage; PVL, periventricular leukomalacia. Values are number (percentage) unless otherwise indicated. P > 0.05 for all comparisons. Ventilator free days = 28-x, if the patient successfully weaned from mechanical ventilation within 28 days, where the x is the number of days spent receiving mechanical ventilation; Ventilator free days = 0, if the patient dies before 28 days or of the patient requires mechanical ventilation for more than 28 days

Discussion

NARDS

ARDS is defined by radiographic diagnosis of diffuse bilateral alveolar infiltrates, the degree of hypoxemia, lung function, and histopathology, and it occurs in all age groups.

ARDS and respiratory distress syndrome (RDS) in neonates show the same clinical characteristics, and differentiation of the two syndromes is justified on the basis of pathophysiologic and etiologic differences [6]. NARDS was not defined in neonates until 2017, when De Luca et al. published an article describing the biologic and pathophysiologic features of NARDS as being similar to those seen in older children and adults with ARDS [4].

We only focused on pneumonia-induced ARDS which defines ARDS more accurately especially for late preterm infants. It is generally accepted that the degree of hypoxemia and ventilator support (as reflected by mean airway pressure) can predict outcome [2], and we therefore stratified infants with NARDS into three categories based on OI. This definition stipulates OI thresholds of 4.0–7.9 for mild NARDS, 8.0–15.9 for moderate NARDS, and 16.0 or higher for severe NARDS [7, 8].

Calsurf treatment improves OI but has no effect on survival rate

Many therapies are currently being evaluated in pediatric patients, including lung-protective ventilation strategies, inhaled nitric oxide, extracorporeal membrane oxygenation (ECMO), and surfactant treatment [3]. NARDS is biologically characterized by qualitative or quantitative surfactant dysfunction that affects proteins and phospholipids, and the afflicted neoantes show extensive inflammation of their pulmonary tissues [9, 10]. Two studies of recombinant surfactant protein in NARDS indicated improvement in oxygenation but without an effect on survival [11, 12], and a follow-up analysis of the study suggested patients with severe NARDS from pneumonia had an improvement in a 28-day survival after surfactant administration [12]. Calsurf is extracted from newborn bovine lungs, is produced in China, and has been used here for several years. Chinese clinical trials by Kong et al. showed that Calsurf supplementation improved pulmonary status when given to preterm infants with severe RDS [13, 14], and Cogo P et al. reported that compared to treatment with 200 mg/ kg of porcine surfactant , 100 mg/kg of porcine surfactant increased the risk of reuse. However, it is not possible to use such high doses of bovine surfactants; this is one of the major reasons of the inferiority of bovine compared to porcine surfactant [15-17]. Regarding to the selection of drug dosage, Chinese clinicians performed several single center clinical studies (publishing their data in Chinese journals), and concluded that both low(40 mg/kg) and high(100 mg/kg) dose Calsurf manifested similar curative effects on mild to moderate RDS’ however, for severe RDS, higher dose Calsurf showed better results[18, 19]. Thus, we used the higher dose of bovine surfactants in the current study, and showed that the OI in the Calsurf group was significantly lower than in the control group after surfactant administration. In the stratified study, the results were equivalent in mild, moderate, and severe cases of NARDS, and these results are somewhat consistent with those reported by Wilson and Luo, who demonstrated that surfactant acutely improved oxygenation and significantly decreased mortality in children and adolescents with ARDS [20, 21].

The mortality rate of infants with NARDS was proximately 5% in our study, while severe NARDS manifested the highest mortality rate (15%). The rate of complications did not differ between the two groups, and some investigators have suggested that the mortality rate in children is lower than in adults-ranging between 18% and 27% [22]. Wong reported that mortality was approximately 30.3% in his study of pediatric patients with ARDS [23], while in our study we found that the mortality rate in infants with NARDS was much lower than in older children. There have no differences in the secondary outcomes as these are extremely multifactorial and it is difficult that surfactant can change this.

Limitations

To the best of our knowledge, this is the first study to describe the effects of surfactant in treating NARDS. However, there are limitations to this study. First, for preterm infants under 34 weeks of gestation, clinicians have some difficulties to the differential definition of neonatal RDS and NARDS, thus to standardize the definition for all the 12 NICUs, preterm babies under 34 weeks of gestation were not included in our study. The mortality rate recorded herein, therefore, might not reflect the overall NARDS. Second, there are two kinds of surfactants in Chinese market: bovine surfactant and porcine surfactant. Exclusively bovine surfactants were used in this study; however, the results could not be applied to other surfactants. Thirdly, because there is lack of phase I/II studies about Calsurf dose range, we do not know whether 100 mg/kg is the best dose for treating NARDS, thus more dose ranging studies for Calsurf are needed. Moreover, the lack of the information about SNAPPE-II score is another limitation, since it is a better indicator to compare the severity of the disease between the two groups. In addition, not every center can provide inhaled NO and ECMO, so these two treatments were not assessed in the current study.

Conclusion

Calsurf acutely improved oxygenation immediately after administration in pneumonia-induced NARDS at a gestational age beyond 34 week. However, we recommend that surfactant should be used cautiously in pneumonia-induced NARDS.

(PNG 3697 kb)

High resolution image (TIF 301 kb)

What is known: • The definition proposed as the Monteux criteria for neonatal acute respiratory distress syndrome (NARDS). • Surfactant acutely improved oxygenation and significantly decreased mortality in children and adolescents with acute lung injury.

What is new: • This is the first large randomized controlled trail to study on surfactant treatment of neonates with acute respiratory distress syndromes. • Surfactant acutely improved oxygenation immediately after administration in pneumonia-induced NARDS at a gestational age beyond 34 weeks