Leontina Lipan1, Bogdan Rusu2, Esther Sendra1, Francisca Hernández3, Laura Vázquez-Araújo4,5, Dan Cristian Vodnar2, Ángel A Carbonell-Barrachina1. 1. Department of Agro-Food Technology, Research Group "Food Quality and Safety", Universidad Miguel Hernández de Elche, Escuela Politécnica Superior de Orihuela, Alicante, Spain. 2. Faculty of Food Science and Technology, University of Agricultural Sciences and Veterinary Medicine Cluj-Napoca, Cluj-Napoca, Romania. 3. Department of Plant Science and Microbiology, Research Group "Plant Production and Technology", Universidad Miguel Hernández de Elche, Escuela Politécnica Superior de Orihuela, Alicante, Spain. 4. BCCInnovation, Technological Center in Gastronomy, Donostia-San Sebastián, Spain. 5. Basque Culinary Center, Mondragon Unibersitatea, Donostia-San Sebastián, Spain.
Abstract
BACKGROUND: The combination of the nutritional profile of almond milk with the benefits of probiotic bacteria is an interesting development to meet the demand for sustainable and health-promoting food. Almond milk inoculated with probiotic Lactobacillus plantarum (ATCC8014) was spray dried and the almond, its milk, and powders were characterized physicochemically. Samples were characterized in terms of bacterial survival before and after atomization. Bacterial viability and total fatty acid changes were studied during 8 months' storage at 4 and 22 °C. RESULTS: Results showed adequate physicochemical properties and an optimal bacterial survival rate, maintaining almost the same values before and after the spray-drying operation. A decrease was observed in the cell viability for samples stored at 4 °C. However, the cell count was maintained above the minimum level suggested (107 living cells) to allow potential probiotic functionality for 8 months. On the other hand, the count cell of powders stored at 22 °C was below the minimum level required after 6 months. The fatty acids profile was not significantly (P > 0.05) affected by storage time and temperature. CONCLUSION: A new almond-based-product with probiotics was developed to meet consumer demands. Almond nutrients were recovered from almond milk powder and were found to be a good source of K and high in Mg and in monounsaturated fat. The viability of bacteria was assured during 8 months of storage at 4 °C and up to 6 months for samples stored at 22 °C.
BACKGROUND: The combination of the nutritional profile of almond milk with the benefits of probiotic bacteria is an interesting development to meet the demand for sustainable and health-promoting food. Almond milk inoculated with probiotic Lactobacillus plantarum (ATCC8014) was spray dried and the almond, its milk, and powders were characterized physicochemically. Samples were characterized in terms of bacterial survival before and after atomization. Bacterial viability and total fatty acid changes were studied during 8 months' storage at 4 and 22 °C. RESULTS: Results showed adequate physicochemical properties and an optimal bacterial survival rate, maintaining almost the same values before and after the spray-drying operation. A decrease was observed in the cell viability for samples stored at 4 °C. However, the cell count was maintained above the minimum level suggested (107 living cells) to allow potential probiotic functionality for 8 months. On the other hand, the count cell of powders stored at 22 °C was below the minimum level required after 6 months. The fatty acids profile was not significantly (P > 0.05) affected by storage time and temperature. CONCLUSION: A new almond-based-product with probiotics was developed to meet consumer demands. Almond nutrients were recovered from almond milk powder and were found to be a good source of K and high in Mg and in monounsaturated fat. The viability of bacteria was assured during 8 months of storage at 4 °C and up to 6 months for samples stored at 22 °C.