Peng Lu1,2, Yue Xing1,2, Hui Peng1,2, Zhidong Liu1,2, Qi Tony Zhou3, Zhifeng Xue1,2, Zhe Ma1,2, Dereje Kebebe1,2,4, Bing Zhang1,2, Hongfei Liu5. 1. Tianjin State Key Laboratory of Modern Chinese Medicine, Tianjin University of Traditional Chinese Medicine, Tianjin, China. 2. Engineering Research Center of Modern Chinese Medicine Discovery and Preparation Technique, Ministry of Education, Tianjin, China. 3. Department of Industrial and Physical Pharmacy, College of Pharmacy, Purdue University, West Lafayette, Indiana. 4. School of Pharmacy, Institute of Health Science, Jimma University, Jimma, Ethiopia. 5. College of Pharmacy, Jiangsu University, Zhenjiang, China.
Abstract
Background: Salvia miltiorrhiza polyphenolic acid (SMPA) is effective in the treatment of cardiovascular diseases and currently it is administered orally or intravenously. However, SMPA is poorly absorbed orally and quickly eliminated in vivo. A long-term frequent intravenous administration leads to poor patient compliance. Therefore, it is urgently demanded to find a new alternative route of noninjection drug delivery system for SMPA. Methods: Two dry powder inhalation (DPI) formulations of spray-dried SMPA formulation (P1) and spray-dried SMPA-L-leucine formulation (P2) were prepared by spray drying method and their physicochemical properties were assessed by thermogravimetric analysis, X-ray diffraction, scanning electron microscopy, particle size distribution analysis, and in vitro aerodynamic analysis. Moreover, In vitro cytotoxicity of SMPA and P2 was conducted with NR8383 cells. In vivo pharmacokinetics were carried out by Penn-Century endotracheal intubation technique to deliver P2 to the lungs of rats. Results and Conclusions: The moisture content of P1 and P2 were 5.81% ± 0.005%, and 4.08% ± 0.002%, respectively. P1 and P2 were in an amorphous state. Moreover, P1 had slightly corrugated surfaces, whereas P2 exhibited severely corrugated surfaces with invagination due to the presence of L-leucine. In addition, there were more hollow particles with smooth surface in P1 than that in P2. Compared with P1, P2 has shown optimal physical particle size and aerosolization behavior with D (v, 50) of 2.64 ± 0.01 μm and fine particle fraction of 37.55% ± 2.63%. The findings of in vitro cytotoxicity showed that P2 did not inhibit cell viability and could be safe for pulmonary administration. The absolute bioavailability of salvianolic acid B (Sal B) for pulmonary administration was 19.15% ± 7.44%, which is significantly higher than the oral bioavailability of Sal B (<5.56%). In this study, we have shown the feasibleness of pulmonary administration of SMPA in the form of DPIs for systemic delivery to treat cardiovascular diseases.
Background: Salvia miltiorrhiza polyphenolic acid (SMPA) is effective in the treatment of cardiovascular diseases and currently it is administered orally or intravenously. However, SMPA is poorly absorbed orally and quickly eliminated in vivo. A long-term frequent intravenous administration leads to poor patient compliance. Therefore, it is urgently demanded to find a new alternative route of noninjection drug delivery system for SMPA. Methods: Two dry powder inhalation (DPI) formulations of spray-dried SMPA formulation (P1) and spray-dried SMPA-L-leucine formulation (P2) were prepared by spray drying method and their physicochemical properties were assessed by thermogravimetric analysis, X-ray diffraction, scanning electron microscopy, particle size distribution analysis, and in vitro aerodynamic analysis. Moreover, In vitro cytotoxicity of SMPA and P2 was conducted with NR8383 cells. In vivo pharmacokinetics were carried out by Penn-Century endotracheal intubation technique to deliver P2 to the lungs of rats. Results and Conclusions: The moisture content of P1 and P2 were 5.81% ± 0.005%, and 4.08% ± 0.002%, respectively. P1 and P2 were in an amorphous state. Moreover, P1 had slightly corrugated surfaces, whereas P2 exhibited severely corrugated surfaces with invagination due to the presence of L-leucine. In addition, there were more hollow particles with smooth surface in P1 than that in P2. Compared with P1, P2 has shown optimal physical particle size and aerosolization behavior with D (v, 50) of 2.64 ± 0.01 μm and fine particle fraction of 37.55% ± 2.63%. The findings of in vitro cytotoxicity showed that P2 did not inhibit cell viability and could be safe for pulmonary administration. The absolute bioavailability of salvianolic acid B (Sal B) for pulmonary administration was 19.15% ± 7.44%, which is significantly higher than the oral bioavailability of Sal B (<5.56%). In this study, we have shown the feasibleness of pulmonary administration of SMPA in the form of DPIs for systemic delivery to treat cardiovascular diseases.
Entities:
Keywords:
Salvia miltiorrhiza polyphenolic acid; dry powder inhalation; in vitro cytotoxicity; in vivo pharmacokinetics; pulmonary administration