Initial experience with the unrestricted introduction of sugammadex at a large academic medical center: a retrospective observational study examining postoperative mechanical ventilation and efficiency outcomes.

BACKGROUND: Sugammadex rapidly reverses deep neuromuscular blockade, but owing to cost, questions remain about its optimal utilization. After the unrestricted introduction of sugammadex at Emory University Hospital, we hypothesized that reductions would be demonstrated in the primary outcome of post-anesthesia care unit (PACU) mechanical ventilation (MV) and secondary outcomes of PACU length of stay (LOS) and emergence time (surgery end to anesthesia end time in the PACU).
METHODS: This retrospective observational study included patients undergoing general anesthesia over a 12-month period. Using multiple variable penalized logistic regression in a one-group before-and-after design, we compared the categorized rates of PACU MV to examine the effect of sugammadex introduction following a post-hoc chart review to ascertain the reason for postoperative MV. Additionally, multiple variable linear regression was used to assess for differences in PACU LOS and emergence time within a propensity-matched set of patients receiving neostigmine or sugammadex.
RESULTS: In total, 7,217 surgical cases met the inclusion criteria: 3,798 before and 3,419 after sugammadex introduction. The incidence of PACU MV was 2.3% before and 1.8% after (P = 0.118) sugammadex introduction. PACU MV due to residual neuromuscular blockade (rNMB) decreased from 0.63% to 0.20% (P = 0.005). Ventilation because of other causes was unchanged. PACU LOS and emergence time were unchanged in the propensity-matched set of 1,444 patients.
CONCLUSIONS: rNMB was an important contributor to PACU MV utilization and its incidence significantly decreased after sugammadex introduction. The selected efficiency measures may not have been sufficiently granular to identify improvements following introduction.

Introduction

Sugammadex is capable of directly reversing the effects of aminosteroidal neuromuscular blocking agents (NMBAs, e.g., rocuronium and vecuronium), by forming tight water-soluble complexes at a 1 : 1 ratio [1]. Compared to cholinesterase inhibitors, NMBA antagonism with sugammadex results in faster recovery and the ability to completely recover from even profound blockade, thus conferring the potential to eliminate residual neuromuscular blockade (rNMB) in routine practice [1-7]. Between 16–60% of patients reversed with neostigmine will demonstrate signs of rNMB, contributing to morbidity from postoperative pulmonary complications (PPCs), such as hypoxemia, airway obstruction, and pneumonia [5,6,8]. Owing to the limited efficacy of cholinesterase inhibitors, some patients cannot be safely extubated at the conclusion of surgery, either because of rNMB following attempted antagonism or blockade that is too profound to even attempt antagonism [9,10]. This could beget increased utilization of operating room time after the conclusion of surgery or the decision to unexpectedly employ mechanical ventilation (MV) in the post-anesthesia care unit (PACU).

Although sugammadex has been available globally since 2008, it did not receive United States (US) Food and Drug Administration approval until December 2015. As a result, US practitioners, practice groups, and hospitals must decide if and how to incorporate sugammadex during routine clinical practice, which is influenced in part by its high direct costs [11]. However, there may be opportunities for indirect savings. For example, postoperative MV is associated with longer PACU stays and increased financial burden [5,12,13]. A decrease in postoperative MV would be expected to result in lessened PACU length of stay (LOS) and decreased provider workload, favorably impacting the pharmacoeconomic analyses underpinning sugammadex utilization decisions [10,14]. Similarly, the ability of sugammadex to completely reverse NMB at nearly any level could result in more rapid intraoperative recovery times.

We sought to examine practical outcomes after the introduction of sugammadex for unrestricted use by anesthesia providers at Emory University Hospital. We hypothesized that there would be a reduction in the primary outcome of PACU MV. Likewise, we anticipated reductions in the secondary outcomes of PACU LOS and the time from surgery stop to anesthesia stop (“emergence time”).

Materials and Methods

We conducted a retrospective observational study of routinely recorded data between October 1, 2015 and October 1, 2016 to examine the clinical and efficiency outcomes following the unrestricted introduction of sugammadex into practice at Emory University Hospital. This study was approved by the Emory University Institutional Review Board (#IRB00092068), including a waiver of informed consent given minimal risk. This manuscript conforms with the applicable EQUATOR checklist for observational studies (STROBE).

Outcomes

One primary outcome was specified a priori: (1) the rate of PACU MV. Three secondary outcomes were analyzed. The first two were specified a priori: (2) PACU LOS and (3) emergence time. As discussed subsequently, an additional secondary outcome was specified post-hoc: (4) rate of PACU MV by cause. PACU LOS was defined as the time between anesthesia end time and readiness for PACU discharge as is routinely documented.

Design

The design was quasi-experimental with a one-group pre/post design for outcomes (1) and (4) and multiple variable regression with propensity score matching for outcomes (2) and (3). The study period was chosen to allow for the assessment of a sufficient number of ventilated patients while maintaining the feasibility of manual chart review to identify a cohort for outcomes (1) and (4); a formal power analysis was not performed.

The study was divided into two time periods: six and a half months before (P1, October 1, 2015 to April 12, 2016) and five and a half months after (P2, April 13, 2016 through October 1, 2016) sugammadex was made available. Once added to the hospital formulary, sugammadex was supplied as part of a standard medication tray for every surgical case without restrictions on provider use. Prior to introduction, providers were educated about its use. Neostigmine and glycopyrrolate were included in the same tray. Choice of NMBA antagonist was at the discretion of the care team. Qualitative nerve monitors were available for all surgical cases, and quantitative monitors (i.e., accelerometers) were available on request.

Data acquisition

Using structured queries against the Emory Healthcare Clinical Data Warehouse (CDW), we identified for inclusion all surgical cases performed using general endotracheal anesthesia (GETA), had an electronic anesthesia record during the study period, and had recovered in the PACU. Patients who were already intubated prior to their procedure and those who did not recover in the PACU (direct ICU admission) were excluded. For each patient, age, sex, height, weight, American Society of Anesthesiologists Physical status classification (ASA-PS), glomerular filtration rate, and surgical specialty data were extracted from the CDW. NMBAs and antagonists used, as well as timestamps for anesthesia and surgery start/stop, PACU admission time, and routinely recorded readiness for PACU discharge were also extracted. For outcome (2), PACU LOS reflected the span of time between admission to the PACU and readiness for discharge, not the time when patients physically left the PACU. With regards to outcome (3), some patients were ready for transport from the operating room to the PACU, but PACU staff were not available to assume care of the patient. The cases of such patients are flagged with a “PACU hold” time per protocol at our institution. The time between surgery end and the PACU hold time was used for outcome (3) in these instances.

Data validation and review

First-pass identification of patients with possible mechanical ventilation in the PACU was performed by identifying within the CDW respiratory therapy interventions (i.e., documented ventilation mode) during the PACU phase of care. This approach was validated against known cases of PACU mechanical ventilation. Further confirmation of PACU mechanical ventilation was made using a detailed manual chart review by two investigators (CM and MM). After obtaining the results from the analysis of outcome (1), a post-hoc determination of the reason for PACU MV was undertaken on a per-case basis by two investigators (CM and MM). These causes were assigned to categories, subject to review and confirmation by two additional investigators (GL and VO), who also refereed disagreements. This analysis led to the examination of secondary outcome (4). In addition to a major category assignment, one or more subcategories were assigned to each. Specifically, for categorization of PACU MV due to rNMB, which was defined as any of the following: documentation of train-of-four (TOF) < 4 at case end, documentation of TOF with subjective fade at case end, documentation of TOF ratio < 0.9 (by accelerometry) at case end, or free-text documentation of rNMB by the intraoperative or PACU anesthesia providers.

Statistical analysis

Following the identification of surgical cases with complete data from P1 and P2, further statistical analysis was performed using R v 3.3 (R Core Team, Austria) [15]. A significance level α of 0.05 was used for all statistical tests. For single variable analysis, categorical data were analyzed using chi-squared tests, while continuous data were analyzed using t-tests (except for case length, which was analyzed using the Wilcoxon rank-sum test), using functions included in the base installation of R.

The dependent variables included (1) a binomial categorization PACU MV, (2) the logarithm of PACU LOS time, (3) the logarithm of emergence time, and (4) binomial categorization of PACU MV by cause. The independent variables included patient age, sex, height, log weight, categorized ASA-PS (1/2, 3, 4/5, or Emergency [any]), categorized estimated glomerular filtration rate (< 30, 30–60, or > 60 ml/min/m2), surgical specialty type, and log case length (time from surgery start to surgery stop as documented in the intraoperative record). Data were manually inspected, transformed to normality if necessary, and outlier cases were removed. Baseline distribution and transformation to normality, if performed, were assessed graphically by inspecting quantile-quantile plots generated using a normal distribution to model theoretical quantiles. The exclusion criteria and number of cases excluded are shown in Fig. 1. Height displayed satisfactory characteristics of normal distribution without transformation. Age was not normal in distribution, and uncomplicated transformations via root or logarithm did not yield improvement. Age was therefore left untransformed for regression analysis [16]. Cases with missing data for any of the dependent variables were excluded from the complete case regression analysis. A dummy dependent variable (Era) was included in both types of regression modeling described below, where Era = 0 was assigned for P1 and Era = 1 was assigned for P2.

Fig. 1.

Study profile with case numbers, exclusions, and main findings related to mechanical ventilation in the post-anesthesia care unit. All patients to the left of center are from P1, and all patients to the right of center are from P2. GETA: general endotracheal anesthesia, PACU: post-anesthesia care unit, NIPPV: non-invasive positive pressure ventilation, rNMB: residual neuromuscular blockade.

Owing to the relatively low incidence of the binomial outcomes of interest (1) and (4), resulting in complete separation in some of the categorical control variables, a penalized-likelihood logistic regression analysis was performed using Firth’s method via the “logistf ” package in R [17-19]. Sensitivity analysis was performed using standard logistic regression by collapsing certain categorical control variables that had complete separation without this combination of categories. Interrupted time series analysis including the time factor was not attempted because of the rarity of the events in the time series. Likelihood ratio tests were performed to determine the significance of the contribution of each dependent variable included in the model.

For outcomes (2) and (3), we analyzed only cases in P2. We assigned an additional dummy variable to each of these cases to indicate whether they had received only neostigmine or only sugammadex. Cases not administered either of these drugs, or both, were excluded. We then performed propensity matching using the genetic algorithm within the “MatchIt” R package [20,21]. As described by Ho et al. [21], this approach uses “a genetic search algorithm to find a set of weights for each covariate such that optimal balance is achieved after matching.” This methodology samples with replacement to optimize the global propensity score, and searches for an optimal matched pool from both the “treatment” group (sugammadex) and the “control” group (neostigmine) rather than finding a 1 : m ratio matched group. For sensitivity analysis, other algorithms for matching were also employed (greedy nearest neighbor, optimal, and coarsened exact matching). Matching was performed on the following independent variables: age, sex, weight, ASA-PS, renal function categorization, case length, and surgical specialty. Owing to residual imbalance, we performed multiple variable ordinary least squares linear regression by using the entire cohort as well as the matched samples. This was performed using the glm function of the “stats” package in R, included in the base installation. The dependent variables in these analyses were outcomes (2) and (3). The independent variables were those described for matching as well as the dummy variable for neostigmine/sugammadex. Emergence times between 2 min and 150 min were included in that regression analysis. Because we were working with log-transformed outcomes of interest, following linear regression, the resultant coefficients were exponentiated and adjusted as to determine the estimate of the percentage change associated with (a) each categorical independent variable compared to the referent or (b) with a one-unit change in continuous independent variables [22]. This was a reasonable approximation for a 1% change in our log-transformed dependent variables as well.

Results

Patient characteristics

There were 4,778 cases in P1 and 4,337 in P2 who received GETA. After excluding cases not recovered in the PACU and those with missing data, 3,798 cases in P1 and 3,419 in P2 were included in the final analytic dataset. Characteristics of the cases analyzed are summarized in Table 1. The majority of patients were female, had ASA-PS 3, and represented a range of surgical specialties, the most common being general and oncologic surgery. The patient populations and case characteristics were similar in both time periods for all of the examined characteristics except median height (167.6 cm vs. 170.2 cm, P = 0.035) and case length (109 min vs. 105 min, P = 0.008).

Table 1.

Patient, Surgical Case, and Neuromuscular Blocking/Reversal Agent Use Characteristics before (P1) and after (P2) Sugammadex Availability amongst those Receiving General Endotracheal Anesthesia with Recovery in the PACU

	P1 (n = 3,798)	P2 (n = 3,419)	P value
Age (yr)*	55.1 ± 16.1	54.4 ± 15.9	0.062
sex (Female)‡	2,151 (56.6%)	1,925 (56.3%)	0.795
Height (cm)*	167.6 (131.2–208.3)	170.2 (134.5–203.2)	0.035
Weight (kg)*	79.4 (31.3–198.6)	79.5 (30–231.8)	0.245
GFR (ml/min/m2)‡			0.442
< 30	313 (8.2%)	285 (8.3%)
30–60	451 (11.9%)	439 (12.8%)
> 60	3,034 (79.9%)	2,695 (78.8%)
ASA classification‡			0.059
1/2	1,227 (32.3%)	1,070 (31.3%)
3	2,089 (55%)	1,882 (55%)
4/5	307 (8.1%)	316 (9.2%)
Emergency (any)	175 (4.6%)	151 (4.4%)
Case length (min)†	109 (56–177)	105 (50–176)	0.034
Surgical specialty‡			0.094
Cardiac/thoracic/vascular	481 (12.7%)	439 (12.8%)
General/oncology	1,281 (33.7%)	1,111 (32.5%)
Neurosurgery	614 (16.2%)	494 (14.4%)
Urology	518 (13.6%)	488 (14.3%)
Gynecology	224 (5.9%)	208 (6.1%)
Gastroenterology	410 (10.8%)	436 (12.8%)
Other	270 (7.1%)	243 (7.1%)
Neuromuscular blocking agents‡	3,713 (97.8%)	3,330 (97.4%)	0.351
Rocuronium	2,917 (76.8%)	2,623 (76.7%)	0.954
Vecuronium	431 (11.3%)	334 (9.8%)	0.033
Cisatracurium	265 (7.0%)	219 (6.4%)	0.356
Succinylcholine	1,091 (28.7%)	892 (26.1%)	0.013
None	85 (2.2%)	89 (2.6%)	0.351
Received any NMBA‡	3,185 (83.9%)	2,874 (84.1%)	0.842
NMBA and neostigmine	2,886 (90.6%)	883 (30.7%)	< 0.001
NMBA and sugammadex	0 (0%)	1,767 (61.5%)	< 0.001
NMBA and no reversal	299 (9.4%)	238 (8.3%)	0.142

Values are expressed as mean ± SD or number (%) or median (IQR). GFR: glomerular filtration rate, ASA: American Society of Anesthesiologists, NMBA: nondepolarizing neuromuscular blocking agent. P values calculated using t-tests (*continuous), Wilcoxon rank-sum (†case length), or chisquared analysis (‡categorical). Totals may exceed 100% as some patients received multiple agents.

NMBA and antagonist agents

Nearly all patients undergoing GETA received a NMBA in P1 and P2, with rocuronium being used in a majority of cases in both P1 and P2. The use of vecuronium and succinylcholine was lower in P2 by a small but statistically significant margin (Table 1). Some cases received more than one NMBA, including multiple nondepolarizing agents. While the percentage of cases given any antagonist (neostigmine, sugammadex, or both) following a nondepolarizing NMBA was > 90% in both P1 and P2, neostigmine use dropped from 90.6% to 30.7% (P < 0.001), representing a two-thirds decrease following the introduction of sugammadex. Sugammadex became the antagonist of choice after its introduction and was used in 61.5% of cases receiving NMBA during P2. A small number of cases (n = 14) received both neostigmine and sugammadex during P2, suggesting sugammadex was used as a rescue agent following attempted NMBA antagonism with neostigmine.

MV in the PACU

The rates and causes of PACU MV are shown in Table 2. Major causes included respiratory/airway, hemodynamic, neurological, or iatrogenic ones, as well as rNMB and lack of intensive care bed (did not plan to extubate) (Appendix, Table S1, for additional detail). The overall incidence of PACU MV was 86 of 3,798 cases (2.3%) in P1 and 60 of 3,419 (1.8%) in P2. Multiple variable penalized-likelihood logistic regression using Firth’s method demonstrated no overall difference after accounting for the control variables. We proceeded to perform an analogous multiple variable regression analysis against each of the identified overall reasons for PACU MV. The results of these regression analyses, reporting only the significance of the difference between P1 and P2, are also shown in Table 2. The rate of PACU MV due to rNMB decreased significantly, from 24 cases in P1 (0.63%) to 7 in P2 (0.20%; P = 0.005). MV because of other causes was not statistically significant. Sensitivity analysis performed with standard logistic regression yielded virtually identical results, with a significant change in PACU MV rate due to rNMB (P = 0.008), and none of the other causes yielded a statistically significant change in PACU MV (not shown).

Table 2.

Rates and Causes of Post-anesthesia Care Unit Mechanical Ventilation before (P1) and after (P2) the Introduction of Sugammadex into Clinical Care

Cause of PACU mechanical ventilation	Total	Pre (P1)	Post (P2)	Odds ratio of PACU mechanical ventilation in the post-introduction era versus the pre-introduction era (95% CI)	P value
Did not plan to extubate	32 (21.9%)	19 (22.1%)	13 (21.7%)	0.772 (0.373–1.551)	0.469
Hemodynamic	18 (12.3%)	6 (7.0%)	12 (20.0%)	2.030 (0.807–5.616)	0.134
Iatrogenic	16 (11.0%)	11 (12.8%)	5 (8.3%)	0.546 (0.182–1.451)	0.230
Neurological	18 (12.3%)	11 (12.8%)	7 (11.7%)	0.792 (0.297–1.992)	0.622
Respiratory	31 (21.2%)	15 (17.4%)	16 (26.7%)	1.124 (0.557–2.282)	0.108
rNMB	31 (21.2%)	24 (27.9%)	7 (11.7%)	0.339 (0.139–0.736)	0.005
All except rNMB	115 (78.8%)	62 (72.1%)	53 (88.3%)	0.938 (0.645–1.358)	0.733
All causes	146	86	60	0.767 (0.547–1.069)	0.118

Values are expressed as number (%). PACU: post-anesthesia care unit, rNMB: residual neuromuscular blockade. P values were derived by performing multiple variable logistic regression as described.

PACU LOS and emergence times

We developed a propensity-matched cohort of patients from P2 who were reversed with either neostigmine or sugammadex (n = 1,444 patients; characteristics summarized in Appendix, Table S2). We performed linear regression to test for an independent association of sugammadex with a difference in PACU LOS and emergence time. The results of these analyses are presented in Tables 3 and 4, respectively. Owing to residual imbalance, factors independently associated with longer PACU LOS included female sex, increasing age, increasing weight, better renal function, non-emergency surgery, longer case length, and certain procedural categories. Factors associated with longer emergence times included longer surgical duration and certain procedural categories. No difference was observed in either outcome between reversal with neostigmine or reversal with sugammadex, in either the propensity-matched cohort or in the unadjusted cohort (not shown). We chose a genetic propensity-matching algorithm as it resulted in the best balance of preserved sample size and matched profile as measured by distance reduction and balance improvement. The detected associations were not substantively different if alternative propensity-matching algorithms were employed. These sensitivity analyses were performed to assess for improved balance over the genetic algorithm and to ensure that the specific matching algorithm used was not a contributing factor to our findings.

Table 3.

Linear Regression on a Propensity-matched Sample Examining the Percentage Change in the Post-anesthesia Care Unit Length of Stay Associated with Neostigmine Versus Sugammadex Administration

OLS regression on the propensity-matched cohort (n = 1,444)	Percentage change in PACU LOS and 95% CI			Univariable P value (Overall LR per ind. var. /vs. reference category)
	% Change	95% CI (low)	95% CI (high)
Reversal agent				LR P = 0.701
Neostigmine	Referent	Referent	Referent	Referent
Sugammadex	1.20%	−5.0%	7.90%	0.702
Age (yr)				LR P = 0.023
Age at visit	0.25%	0.04%	0.47%	0.023
Sex				LR P = 0.017
Female	Referent	Referent	Referent	Referent
Male	−8.0%	−14.1%	−1.5%	0.017
Weight				LR P = 0.014
log Weight (kg)	17.37%	3.26%	33.40%	0.014
Renal function category (ml/min/m2)				LR P = 0.036
GFR < 30	Referent	Referent	Referent	Referent
GFR 30–60	1.5%	−10.3%	14.9%	0.813
GFR > 60	−9.1%	−18.0%	0.81%	0.071
ASA-PS				LR P < 0.001
ASA-PS 1/2	Referent	Referent	Referent	Referent
ASA-PS 3	5.1%	−2.5%	13.3%	0.198
ASA-PS 4/5	5.8%	−7.0%	20.3%	0.396
ASA-PS Emergency (any)	−24.6%	−36.5%	−10.5%	0.001
Case length				LR P < 0.001
log Case length (min)	24.2%	18.8%	29.9%	< 0.001
Procedure type				LR P < 0.001
Cardio/thorac/vasc	Referent	Referent	Referent	Referent
General/onc	−4.6%	−13.4%	5.3%	0.350
Neurosurgery	15.1%	3.1%	28.5%	0.013
Urology	1.3%	−9.6%	13.4%	0.827
Ob/gyn	−4.3%	−16.9%	10.4%	0.548
Gastroenterology	−28.8%	−40.0%	−15.6%	< 0.001
Other	−19.2%	−29.4%	−7.6%	0.002

OLS: ordinary least-squares, PACU: post-anesthesia care unit, LR: likelihood ratio, ind var: independent variable, GFR: glomerular filtration rate, ASA-PS: American Society of Anesthesiologists physical status, LOS: length of stay, Cardio/thorac/vasc: cardiac, thoracic and vascular surgery, General/one: general and oncologic surgery, and oncologic surgery, Ob/gyn: obstetric and gynecologic surgery.

Table 4.

Linear Regression on a Propensity-matched Sample Examining the Percentage Change in the Emergence Time Associated with Neostigmine versus Sugammadex Administration

OLS regression on the propensity-matched cohort (n = 1,444)	Percentage change in emergence time and 95% CI			Univariable P value (Overall LR per ind. var. /vs. reference category)
	% Change	95% CI (low)	95% CI (high)
Reversal agent				LR P = 0.194
Neostigmine	Referent	Referent	Referent	Referent
Sugammadex	3.20%	−1.6%	8.20%	0.196
Age (yr)				LR P = 0.221
Age at visit	−0.10%	−0.26%	0.06%	0.225
Sex				LR P = 0.829
Female	Referent	Referent	Referent	Referent
Male	−0.56%	−5.5%	4.7%	0.830
Weight				LR P = 0.089
log Weight (kg)	−7.9%	−16.4%	1.3%	0.091
Renal function category (ml/min/m2)				LR P = 0.195
GFR < 30	Referent	Referent	Referent	Referent
GFR 30–60	−6.4%	−14.7%	2.7%	0.163
GFR > 60	−6.7%	−13.6%	0.8%	0.078
ASA-PS				LR P = 0.296
ASA-PS 1/2	Referent	Referent	Referent	Referent
ASA-PS 3	2.5%	−3.1%	8.4%	0.394
ASA-PS 4/5	9.8%	−0.3%	21.0%	0.058
ASA-PS Emergency (any)	4.5%	−8.1%	18.8%	0.505
Case length				LR P < 0.001
log Case length (min)	5.9%	2.4%	9.5%	0.001
Procedure type				LR P < 0.001
Cardio/thorac/vasc	Referent	Referent	Referent	Referent
General/onc	−1.9%	−8.9%	5.5%	0.599
Neurosurgery	22.6%	12.9%	33.2%	< 0.001
Urology	−2.1%	−10.1%	6.6%	0.628
Ob/gyn	−3.8%	−13.5%	7.1%	0.481
Gastroenterology	−6.2%	−17.5%	6.6%	0.326
Other	−9.1%	−17.9%	0.5%	0.063

OLS: ordinary least-squares, LR: likelihood ratio, ind var: independent variable, GFR: glomerular filtration rate, ASA-PS: American Society of Anesthesiologists Physical Status, Cardio/thorac/vasc: cardiac, thoracic and vascular surgery, General/onc: general surgery and oncologic, Ob/gyn: obstetric and gynecologic surgery.

Discussion

The introduction of sugammadex into unrestricted clinical use was associated with a significant reduction in PACU MV due to rNMB, but no change was observed in the studied efficiency outcomes or overall utilization of MV in the PACU. Rates of PACU MV decreased from 0.63% to 0.20% following introduction of sugammadex. Prior descriptions of causes for PACU MV have been scant. We found the causes of PACU MV to be diverse, and rNMB accounted for 27.9% of PACU MV in P1 versus 11.7% in P2. The use of sugammadex likely enabled the reversal and extubation of patients who previously would have otherwise required postoperative MV.

Impact of sugammadex availability on PACU and efficiency measures

Broadly speaking, any rNMB carries a risk of patient discomfort, morbidity, and PPCs [8]. These complications have been well described, and a review of these complications, and the debate surrounding them, are beyond the scope of this report. We studied one of the more extreme consequence of rNMB, namely the need for mechanical ventilation in the PACU. When relying on anticholinesterases for NMBA antagonism, rNMB necessitating PACU MV can occur when a procedure is much shorter than expected, when deep NMB is required until case end, and in patients with unexpectedly prolonged TOF suppression. Related factors may include inexperience or errors with NMBA dosing and monitoring. Previous studies showing that sugammadex has the potential to eliminate rNMB had not reported on its effect on PACU MV [5,23]. Olesnicky et al. [24] recently published an observational study of unrestricted sugammadex use in Australia, reporting a decrease in respiratory diagnoses with sugammadex availability. While they did observe a decrease in PACU MV, from 0.88% to 0.18%, this was not statistically significant, perhaps because of the sample size.

Avoiding PACU MV reduces the workload for PACU staff (nurses, respiratory therapists, and physicians), hastens postoperative recovery, improves PACU efficiency, and avoids excess costs. These implications align with other work identifying earlier discharge readiness in patients who received sugammadex versus anticholinesterases for NMBA antagonism [25]. Although we studied a severe manifestation of rNMB, sugammadex may hasten postoperative recovery and avoid more subtle types of PPCs [10,26,27]. Although we failed to identify improvements in the studied efficiency metrics, these and similar benefits should factor into pharmacoeconomic decisions regarding sugammadex deployment and implementation. Direct costs may be partially or fully offset through indirect savings in certain practice settings. PACU LOS and emergence time are highly complex, multifactorial outcomes that might be better assessed with a prospective observational design to standardize their assessment and allow more granular comparisons in future investigations.

As could be expected, sugammadex was not a panacea for all causes of rNMB. We identified prolonged NMB after succinylcholine administration, renal failure, and failure to administer sugammadex when appropriate as additional factors resulting in the need for PACU MV due to rNMB. Sugammadex is currently not recommended in patients with severe renal impairment owing to concerns related to delayed drug clearance and lack of safety data in this population, and for this reason, providers may rely on anticholinesterases for NMBA antagonism in this patient population [28]. Several studies of sugammadex use in patients with renal failure have demonstrated efficacy without major adverse events, but further study is required to determine whether sugammadex can indeed be used safely in this patient population [26,29,30]. Missed opportunities to prevent PACU MV via sugammadex administration may require education regarding the apparent risk/benefit ratio of sugammadex usage and the system-level improvement in care and value that accompanies avoidance of PACU MV [11].

PACU MV is a rare outcome, and our results should therefore be interpreted with caution, as the study may have been underpowered with regard to the primary outcome and MV-by-cause secondary outcome. Therefore, the findings related to rNMB, while intuitive, should still be considered exploratory. Our study is also subject to limitations inherent to retrospective designs, including the potential for unmeasured confounding. Linear regression of a propensity-matched cohort was used to reduce the selection bias from known covariates of interest in the analyzed sample. We attempted to minimize information bias with respect to misclassification of the causes of PACU MV by ensuring concurrence between multiple investigators. Although these determinations were made by retrospective chart review, a clear trail of evidence from the documentation was present in all cases reviewed. A form of confounding by indication cannot be excluded as patients with greater or lesser likelihood to develop rNMB may have been differentially represented in P1 and P2. This was at least partially addressed through the examination of relevant available covariates, such as case length and renal function. We also cannot fully exclude certain types of cyclic or seasonal influences. For example, the introduction of new trainees into the operating room environment in July 2016 may have influenced the rates of PACU MV in P2. However, this would be expected to contribute, if anything, to an upward bias in MV related to rNMB resulting from the actions of inexperienced care providers in the period from July through October 2016 (P2).

In conclusion, the introduction of sugammadex did not decrease the rate of PACU MV, nor did it decrease the amount of time between surgery end and emergence. However, the introduction of sugammadex did reduce PACU MV secondary to rNMB, while other sources of PACU MV were statistically unchanged. Further work is needed to validate these findings and to understand the overall direct and indirect cost implications of the use of sugammadex rather than traditional pharmacologic methods for the reversal of NMBA.