Long-Term Survival and Thermal Death Kinetics of Enterohemorrhagic Escherichia coli Serogroups O26, O103, O111, and O157 in Wheat Flour.

Wheat flour has been associated with outbreaks of enterohemorrhagic Escherichia coli (EHEC), but little is known on EHEC's survival during storage and thermal processing. The objective of this study was to determine long-term viability and thermal inactivation kinetics of EHEC serogroups O26, O103, O111, and O157. Wheat flour samples were inoculated with a cocktail of five strains of a single serogroup and stored at 23 and 35°C. Inoculated samples were heated at 55, 60, 65, and 70°C. Viability was determined by plate counting. Decimal reduction time (D) and first decimal reduction time (δ) values were calculated with log-linear and Weibull models, respectively. At 23°C, EHEC counts declined gradually for 84 days and samples tested positive from 84 to 280 days. The thermal resistance (D and δ) values ranged from 7.5 to 8.2 and 3.1 to 5.3 days, respectively, but there were no significant differences among serogroups (P ≤ 0.05). At 35°C, no EHEC was quantifiable by day 7 and no positive samples were detected after 49 days. Heating at 55 and 65°C resulted in δ-value ranges of 15.6 to 39.7 min and 3.0 to 3.9 min, respectively, with no significant difference among serogroups either. Z values were 12.6, 6.7, 10.2, and 13.4°C for O26, O103, O111, and O157, respectively. Thermal death kinetics of EHEC in flour were better described using the Weibull model. Survival and inactivation rates of four serogroups were remarkably similar. These findings indicated that all EHEC serovars tested remained viable for at least 9 months at room temperature and survived for up to 60 min at 70°C in wheat flour.IMPORTANCE Enterohemorrhagic Escherichia coli (EHEC) and Salmonella have recently caused several gastroenteritis outbreaks and recalls of wheat flour. Because EHEC can cause illness with very low doses and there is very scarce information regarding their ability to survive storage and heating in flour, the present study was undertaken to assess the long-term survival of EHEC serogroups O26, O103, O111, and O157 in flour. These findings are relevant, as we report that EHEC can survive for more than 9 months in wheat flour during storage. In addition, results obtained suggest that thermal inactivation at 65°C for 30 min or 2 months of storage at 35°C may be feasible strategies to mitigate the risk of most EHEC serovars in wheat flour.