Enhancement of Solubility and Specific Activity of a Cu/Zn Superoxide Dismutase by Co-expression with a Copper Chaperone in Escherichia coli.

BACKGROUND: Human Cu/Zn superoxide dismutase (hSOD1) is an antioxidant enzyme with potential as a therapeutic agent. However, heterologous expression of hSOD1 has remained an issue due to Cu2+ insufficiency at protein active site, leading to low solubility and enzymatic activity.
OBJECTIVES: The effect of co-expressed human copper chaperone (hCCS) to enhance the solubility and enzymatic activity of hSOD1 in E. coli was investigated in the presence and absence of Cu2+.
MATERIALS AND METHODS: pETDuet-1-hSOD1 and pETDuet-1-hCCS-hSOD1 were constructed and individually transformed into E. coli strain BL21(DE3). The recombinant hSOD1 was expressed and purified using immobilized metal affinity chromatography. The yield and specific activity of hSOD1 in all conditions were studied.
RESULTS: Co-expression with hCCS increased hSOD1 solubility at 37°C, but this effect was not observed at 25°C. Notably, the specific activity of hSOD1 was enhanced by 1.5 fold and greater than 3 fold when co-expressed with hCCS at 25°C with and without Cu2+ supplement, respectively. However, the chaperone co-expression did not significantly increase the yield of hSOD1 comparable to the expression of hSOD1 alone.
CONCLUSIONS: This study is the first report demonstrating a potential use of hCCS for heterologous production of hSOD1 with high enzymatic activity.

1. Background

Superoxide dismutase (SOD) is a primary defense that acts to catalytically remove superoxide anions. In mammals, three forms of SOD have been distinguished by metal cofactors and localization (1). Amongst which, SOD1 or Cu/Zn SOD is the one of crucial enzymes, and typically the most abundant one (2,3). SOD1 is a homodimer consisting of two ~16 kDa subunits found in the cytoplasm and nucleus of the cell. It is a metalloenzyme, which its active sites contain two copper and one zinc ions per molecule (4). The copper ions are required for enzymatic activity, whereas the zinc ion only helps to stabilize the enzyme structure (5). Cu/Zn SOD is considered as a therapeutic agent for diseases mediated by oxidative stress (6-8). It has been reported that SOD1 could reduce inflammation (9), protect against reperfusion damage of ischemic tissue (10), and prevent oncogenesis (11). Efficient procedures for SOD1 production are important for clinical applications, therefore, the simple expression and purification procedures with high specific activity are of interest. Heterologous expression of hSOD1 has been conducted in many expression systems including E. coli (12,13), yeast (14,15), insect (16,17) and plant cells (18). However, the most common problem has been that the produced protein is Cu2+-deficient at active site resulting in low solubility and enzyme activity (12-14). The metal reconstitution in vitro is a method to incorporate Cu2+ into the apoenzyme, but it requires low pH that is harmful and consequently results in large losses of protein (19). Although addition of Cu2+ into the E. coli culture was reported to improve the Cu2+ incorporation, the production of Cu/Zn SOD with a full Cu2+ complement was still a complication. This could be due to a lack of Cu2+ delivery system in E. coli.

In eukaryotes, Cu2+ incorporation into the SOD1 in vivo is mediated by the action of the copper metallochaperone (copper chaperone for SOD1 or CCS). Studies with the yeast metallochaperone (yCCS) have shown that yCCS directly incorporates copper into SOD1 despite exquisitely low levels of available free copper (20). Moreover, co-expression of yCCS with human Cu/Zn SOD variants and pseudo-EC-SOD enhanced the protein yields with high copper content in the presence of Cu2+ supplement (19). SOD1 is activated principally via a CCS and to a lesser degree by a CCS-independent pathway of unknown mechanism in mammals (21). However, the effect of co-expression of hCCS on hSOD1 production in E. coli has never been elucidated.

2. Objectives

In this study, the co-expression of hCCS and hSOD1 in E. coli was accomplished in the optimized condition to gain higher SOD1 solubility and specific activity.

3. Materials and Methods

3.1.Construction of Plasmids for Co-expression of hSOD1 and hCCS

E. coli strain NovaBlue (Novagen, Germany) was used for cloning. hSOD1 (GenBank: EF151142.1) was amplified from the pET20b-hSOD1, a construct donated by Prof. Daret K. St. Clair, University of Kentucky, using i-Taq polymerase (Intron Biotechnology, South Korea) with forward (5´- ATACATATGGCGACGAAGGC- 3´, underlined is NdeI restriction site) and reverse (5´-ATTGCTCAGCTTATTGGGCG-3´, underlined is Bpu1102 I). hCCS (GenBank: NM_005125) was amplified using Gene PoolTM cDNA, from human normal brain tissue (Invitrogen, USA) with forward (5´-TGGCCATGGCTTCGGATTCG- 3´, underlined is NcoI restriction site) and reverse (5´- GACAAGCTTTCAAAGGTGGG- 3´, underlined is HindIII restriction site). The 465 bp and 824 bp PCR products of hSOD1 and hCCS, respectively were digested with the corresponding restriction enzymes and purified from agarose gel after electrophoresis. The hSOD1 was ligated into plasmid pETDuet-1 (Novagen, Germany) at multiple cloning site2 (MCS2) to obtain pETDuet-1-hSOD1. The hCCS was subsequently ligated into pETDuet-1-hSOD1 at multiple cloning site1 (MCS1) to obtain pETDuet-1- hCCS-hSOD1. The recombinant plasmids were verified by DNA sequencing.

3.2. Co-expression of hSOD1 and hCCS

The protein expression was carried out in E. coli BL21(DE3) (Novagen, Germany). The transformed strains harboring recombinant plasmids were inoculated and grew for 16 h at 37ºC in LB containing 100 μg.mL-1 ampicillin. The culture was diluted into 3 L terrific broth (TB) containing 100 μg.mL-1 ampicillin and incubated at 37°C, 150 rpm until OD600 of 0.5. The target proteins were induced by addition of isopropyl- β-D-thiogalactopyranoside (IPTG) (Bio Basic Canada Inc. Canada) at a final concentration of 1 mM with/without 50 ppm CuCl2 (Bio Basic Canada Inc. Canada). The cultures were incubated at 25ºC for an additional 16 h. Cells were harvested by centrifugation (20,000 ×g, 20 min) and suspended in buffer A (50 mM phosphate buffer, pH 7.4) followed by sonication. The lysates were cleared by centrifugation at 20,000 ×g for 20 min.

3.3. Purification of hSOD1

The clear lysates were incubated for 30 min at 60°C to precipitate contaminating proteins. Cu/Zn SOD proteins are thermostable proteins, whereas most proteins precipitate at high temperature (19,22). The supernatant was filtered and loaded on a Ni-NTA sepharose column which pre-equilibrated with buffer A (50 mM phosphate buffer, pH 7.4) with ÄKTA prime protein purification system (GE healthcare life sciences, UK). After elution with a linear gradient of buffer B (buffer A + 1 M imidazole), the target protein containing fractions were combined. The imidazole was removed and purified proteins were concentrated by an Amicon Ultra 10,000-MWCO filter (Millipore Corp., USA). Protein molecular weight and purity under denaturing condition were determined by SDS-PAGE. Protein concentrations were measured by Bradford method (23), before storage at -80°C.

3.4. Enzymatic Activity and Spectral Property of hSOD1

SOD activity was measured according to the inhibition of nitroblue tetrazolium (NBT) reduction by superoxide radicals generating from NADH/phenazine methosulfate (PMS) reaction at aerobic and non-acidic pH conditions as previously described (24). The absorbance at 560 nm was monitored during 5 min as an index of NBT reduction using a UV-visible spectrophotometer and calculated the enzyme inhibition (%) to define the half maximal inhibitory concentration values (IC50) and specific enzymatic activity. One unit of SOD activity is defined as the amount of enzyme that causes 50% decrease in NBT reduction.

The absorption spectra in the visible region (500-800 nm) of ~1 mM protein solutions were obtained using a UV-2450 UV-visible spectrophotometer (Shimadzu, Japan).

3.5. Statistical Analysis

Data are presented as mean±standard deviation (SD). Comparison of two means was performed using paired t-test, p-value < 0.05 with 2-tailed t-test. All statistical calculations were performed using PASW statistic 18 (SPSS Inc., USA).

4. Results

In this study, the co-expression of hCCS and hSOD1 in E. coli was accomplished in the optimized condition to gain higher SOD1 solubility and specific activity.

4.1. Construction and Co-expression of hSOD1 and hCCS

In this study, pETDuet-1-hSOD1 and pETDuet-1-hCCS-hSOD1 were successfully constructed (Figure 1).

Figure 1

Construction of pETDuet-1-hSOD1 and pETDuet-hCCS-hSOD1. A: The coding frame of hSOD1 (465 bp) was cloned into MCS2. It is located downstream of 6× His tag. B: The coding frame of hCCS (824 bp) was cloned into MCS1

pETDuet-1, a bicistronic expression vector, contains two multiple cloning sites (MCS1 and MCS2) that each includes a T7 promoter/lac operator and a ribosome binding site. The hCCS was cloned into MCS1 without a tag, whereas the hSOD1 was cloned into a MCS2 with a polyhistidine tag that applied for hSOD1 purification. The transformed E. coli BL21(DE3) strains were cultivated in the medium without CuCl2 supplement. hSOD1 was highly expressed as insoluble form when the expression of pETDuet-1-hSOD1 and pETDuet-1-hCCS-hSOD1 were induced at 37°C (Figure 2).

Figure 2

hSOD1 heterologous expression through the pETDuet-1 expression system. SDS-PAGE showing induction of hSOD1 expression at 37ºC and 25ºC for 16 h. Lane 1 and 10, protein marker; Lane 2-5, fractions from E. coli BL21(DE3) carrying pETDuet-1-hSOD1; Lane 6-9, fractions from E. coli BL21(DE3) carrying pETDuet-1-hCCS-hSOD1; P, insoluble fraction; S, soluble fraction. Arrows indicate expected hCCS and hSOD1 proteins, MW~29 kDa and ~16 kDa, respectively. Results are representative of two separate experiments

However, in the case of co-expression with hCCS, a significant improvement in hSOD1 solubility was observed (Figure 2, lanes 3 and 7). Notably, lowering of induction temperature to 25ºC showed an even more increase in the solubility of hSOD1 with no significant enhancement in solubility in the presence of hCCS (Figure 2, lanes 3, 5, 7 and 9).

4.2. Purification of hSOD1

hSOD1 was further produced from E. coli under low temperature condition. Purification of His-tagged hSOD1 was conducted using immobilized metal affinity chromatography (IMAC). In the absence of hCCS co-expression, hSOD1 was purified to sufficient homogeneity by single step. However, in case of coexpression with hCCS, this copper chaperone could not be removed using only IMAC purification (data not shown). To solve this problem, protein supernatants obtained from E. coli lysates were incubated at 60°C for 30 min and centrifuged to remove the contaminating proteins, particularly hCCS (Figure 3A, lane 3). To examine whether the yields can be enhanced by co-expression of hCCS, E. coli carrying and pETDuet-1-hCCS-hSOD1 were grown in media in the presence or absence of 50 ppm CuCl2 supplement. All supernatants were applied to IMAC column. After purification procedure, the protein samples were resolved by 12% SDS-PAGE to confirm the hSOD1 purity. As shown in Figure 3B, hSOD1 was purified to homogeneity (> 95% purity) in all conditions. The final yields of purified hSOD1 as determined by Bradford were shown in Table 1.

Figure 3

Table 1

Effects of hCCS co-expression on yields of purified hSOD1

Vectors	Supplementation of 50 ppm CuCl2	Yield of hSOD1 protein (mg.L-1 of culture)
pETDuet-1-hSOD1 pETDuet-1-hSOD1 pETDuet-1-hCCShSOD1 pETDuet-1-hCCShSOD1	- + - +	20 31 22 30

Protein expression and purification of recombinant hSOD1. A: Co-expression of hCCS at 25ºC (+CuCl2). Lane 1 protein marker; Lane 2, soluble fraction; Lane 3, soluble fraction after incubation at 60ºC for 30 min. B: Purification of recombinant hSOD1 using IMAC. Lane 1, protein marker; Lane 2, clone carrying pETDuet-1-hSOD1 (-CuCl2); Lane 3, clone carrying pETDuet-1-hSOD1 (+CuCl2); Lane 4 clone carrying pETDuet-1-hCCS-hSOD1 (-CuCl2); Lane 5 clone carrying pETDuet-1-hccs-hsoD1 (+CuCl2)

4.3. Enzymatic Activity and Spectral Property of hSOD1

In eukaryotes, CCS has been known as the chaperone that directly incorporates Cu2+ into SOD1 in vivo. The presence of Cu2+ in the active site of Cu/Zn SOD enzymes is crucial for the activity of the enzyme. To investigate whether co-expression of hCCS enhances the enzymatic activity in E. coli expression system, the specific SOD activity was examined. Apparently, the result showed that co-expression of hCCS significantly increased the specific activity of hSOD1 in both the presence and absence of Cu2+ supplement. The highest activity was observed when supplementing with Cu2+ (Figure 4). The specific activity of hSOD1 produced by hCCS co-expression with Cu2+ supplement was approximately 1.5 fold greater than that of hSOD1 produced without co-expression (4,413±169 and 2,973±40 U.mg-1 protein, respectively). Interestingly, a 3-fold increase in the specific activity of hSOD1 was observed when hCCS was co-expressed as compared with no chaperone (1,298±187 and 414±29 U.mg-1 protein, respectively) in the absence of Cu2+ supplement. Since Cu/Zn SOD has a characteristic spectrum in the visible region with an absorption maximum at 680 nm (25), the visible absorption spectroscopy of the purified proteins was determined. Analysis of spectral property revealed the peak of hSOD1 at 680 nm obtained only from E. coli in Cu2+ supplemented medium (Figure 5). The spectrum was similar to previous study which representing the correct occupation of Cu (II) at active site (25). In contrast, no peak of hSOD1 was observed when E. coli was cultured in medium without Cu2+ supplement.

Figure 4

Figure 5

Specific activity of recombinant hSOD1 from clones with and without hCCS co-expression in the absence or presence of Cu2+ supplementation. One unit of SOD activity was defined as the amount of enzyme that caused 50% decrease in NBT reduction. Error bars represent the standard deviations of results obtained from three experiments in triplicates. The statistical analysis was evaluated by paired t-test. Values that are significantly different (P < 0.05) are indicated by asterisks

Visible absorption spectra of recombinant hSOD1. Spectra were observed and recorded from 1 mM hSOD1 in 50 mM phosphate buffer pH 7.4. The characteristic spectrum of Cu/Zn SOD is in the visible region with an absorption maximum at 680 nm. Solid line, purified hSOD1 (without hCCS, no Cu2+ supplement); dotted line, purified hSOD1 (no Cu2+ supplement, with hCCS); dash line, purified hSOD1 (Cu2+ supplement, without hCCS); dash-dotdot line, purified hSOD1 (Cu2+ supplement, with hCCS)

5. Discussion

hSOD1 is a metalloenzyme, which lack of Cu2+ at active site impairs its structure and maturation leading to low solubility and enzyme activity. Previous study indicated that hCCS is critical for maturation of hSOD1 through insertion of the Cu2+ and oxidization of an intra-subunit disulfide (26). Moreover, it has been demonstrated that hCCS, by interacting with the immature fALS (familial amylotrophic lateral sclerosis) SOD1 mutants, could exert a role of molecular chaperone for SOD1 both in vivo and in vitro (27). Herein, the effect of hCCS co-expression on hSOD1 solubility and enzymatic activity in E. coli expression system was firstly established using pETDuet-1 expression vector. Our results represented that hCCS co-expression significantly increased the hSOD1 solubility at 37ºC but not at 25ºC in the presence of Cu2+ supplement. It is possible that the hCCS functioned at 37°C to reduce protein folding defects, whereas these defects were minimized and protein was folded properly at low temperature. Moreover, the co-expression with hCCS at 25°C did not significantly increase the yield of hSOD1 in both the absence and presence of Cu2+ supplement as compared to the expression of hSOD1 alone. This result indicated that the protein yield seemed to be affected by Cu2+ rather than hCCS. Interestingly, incubation of lysates at 60ºC during purification step did not affect the enzymatic activity of hSOD1. This result is consistent with the previous study that demonstrated the Cu/Zn SOD is a thermostable protein (22). Notably, our expression and purification systems produced higher amounts of recombinant hSOD1 (30 mg.L-1 of culture) when supplementing with Cu2+ as compared to previous study using E. coli (10 mg.L-1 of culture), yeast (7.6 mg.L-1), insect cells (~5-15 mg.L-1 of culture) and protozoa (6.5 mg.L-1 of culture) as expression hosts (13,15,17,28). Although, the different yields might be influenced by the different expression and purification systems used, the advantages of our system when compared to the eukaryotic expression systems are more rapid, simple and cost effective. Our results also demonstrated that co-expression with hCCS in the presence of Cu2+ supplement conferred higher enzymatic activity when compared with no chaperone. Moreover, the effect of hCCS on specific activity was clearly observed in the absence of Cu2+ supplement. This phenomenon suggested that hCCS actively functions in both Cu2+ abundant or depleted conditions, but it is more active in Cu2+ insufficient condition. This finding is in good agreement with the previous study that showed the better activity of yCCS under conditions where the free copper in the cytoplasm is strictly limited (20). Additionally, our results showed that supplementation of Cu2+ could increase the specific activity of hSOD1 in cells lacking of hCCS. This result is consistent with previous study that showed the activation of hSOD1 in vivo could be CCS-independent when copper concentrations were elevated in the growth medium (20). The specific activity of hSOD has been reported in range of 2,700-5,600 U.mg-1 protein, based on different expression hosts (13,15,29). Even though the highest activity was presented when hSOD1 was expressed and purified from transgenic rat tissue (~5,600 U.mg-1 protein), the expression yield was relatively low (29). Apparently, most expression systems demonstrated the lower specific activity of enzyme when compared to that of our system (~4,500 U.mg-1 protein). Interestingly, co-expression of hCCS did not affect the peak of purified hSOD1, although our results apparently showed that the specific activity of hSOD1 dramatically increased when the enzyme was coexpressed with hCCS chaperone. This result is inconsistent with previous study that displayed the coexpression with yCCS increased the metallization of hSOD-proteins with 87-98% copper saturation (19). However, our result is in good agreement with earlier study that showed the co-expression of CotA laccase with CopZ copper chaperone of Bacillus licheniformis in E. coli increased the specific activity of enzyme even though total copper content did not alter (30). Taken together, our results indicate that not only intracellular Cu2+ concentration, but also the presence of an appropriate copper chaperone affects the specific SOD activity. Our procedure is simply and can routinely be used for improved heterologous production of hSOD1 in E.coli.

6. Conclusions

This study firstly elucidates that the co-expression with hCCS in E. coli could increase the hSOD1 solubility and specific activity. Notably, hCCS co-expression affected the hSOD1 solubility when co-expressing at 37°C rather than 25°C. Moreover, the specific activity of hSOD1 was improved when co-expressing with hCCS at 25 °C in both presence and absence of supplementary Cu2+ but the highest activity was observed when supplementing with Cu2+. Interestingly, the effect of hCCS on hSOD1 specific activity was apparently showed in the absence of supplementary Cu2+. In addition, the chaperone coexpression did not significantly enhance the yield of hSOD1 comparable to the expression of hSOD1 alone. However, our expression and purification systems clearly demonstrated the high production of recombinant hSOD1. Taken together, the findings of this study present the application of hCCS in hSOD1 production for therapeutic use in the future.

Acknowledgements

Authors would like to thank Prof. Daret K. St.Clair, University of Kentucky for providing hSOD1.

Funding/Support

This work was supported by the Office of the Higher Education Commission and Mahidol University under the National Research Universities Initiative.