Assessment of AflatoxinM1 Contamination in UHT Flavored Milk Samples in Karaj, Iran.

This study was carried out to detect the presence of aflatoxin M1 (AFM1) in 30 UHT flavored milk samples in Karaj, Alborz province, Iran. High-performance liquid chromatography (HPLC) was applied to analyze AFM1 in the samples. The results showed that aflatoxin M1 was detected in all the UHT flavored milk samples, the AFM1 concentration ranged from 0.015 to 0.14 µg/L. Also, 10 samples (33.3%) were contaminated with more than 0.05 µg/L of European Union regulations for aflatoxin M1. Wherease, according to the proposed Iranian national standard and FDA (0.5 µg/L), none of the samples has not been contaminated more than the maximum AFM1 concentrations threshold. This is the first report discovering the fact that UHT flavored milk is an important contributor to the dietary intake of AFM1 in Iran.

Introduction

Mycotoxins are toxic secondary metabolites produced in several agricultural commodities and foods, during harvesting, storage and processing, also, under suitable conditions of temperature and humidity (1-3). Aflatoxins are the most generally known groups of mycotoxins worldwide, which are produced by the current fungi Aspergillus flavus, A. parasiticus, A. pseudotamarii, A. bombycis, A. ochraceoroseusand A. Nomius (1 ,4). Major kinds of aflatoxins are B1, B2, G1, G2, M1 and M2. They are highly toxic, teratogenic, estrogenic, mutagenic, tremorogenic, immunosuppressive and carcinogenic compounds which have been implicated as causative agent in human hepatic and extrahepatic carcinogenesis (1, 5-6). Among them, aflatoxin B1 (AFB1) is the most potent reason of human carcinogen; therefore, the International Agency for Research on Cancer (IARC) has classified AFB1 and AFM1 into the primary and secondary groups of carcinogenic compounds, respectively (3, 5, 7). When animals eat foodstuffs containing AFB1, these toxins will be metabolized and extracted as AFM1 in milk (1).

Flavored milk is one of the dairy products facing an increased consumption in Iran, also it is most popular among children and infant. Flavored milk is cow’s milk with added sugar, colourings and artificial or natural flavourings. The current available flavours are chocolate, banana, strawberry and vanilla. It contains nine essential nutrients such as calcium, potassium, phosphorus, protein, vitamins A, D and B12, riboflavin and niacin.

Milk and dairy product are a concern for human health, particularly to children worldwide (8). Hence, several countries have set legal regulations to control levels of aflatoxin M1 in milk and dairy products which vary from one country to another (1, 5). Kamkar et al. (1) reported that aflatoxin M1 is resistant to heat treatments such as pasteurization, sterilization (UHT techniques), autoclaving, and other processes like freezing, fermentation and cold storage. Several analytical and immunological analytical techniques such as TLC, ELISA and HPLC are available for determination of AFM1 in milk and dairy products. HPLC methods are very costly, precise, selective, simple and sensitive techniques for aflatoxins analysis (1, 9).

The consumption of flavored milk is common among children and school children. Several studies about aflatoxin occurrence in milk and dairy products have been reported in Iran (1). Hence, the aim of this study was to investigate the first prevalence of AFM1 in UHT flavored milk samples in Karaj, Alborz province, Iran.

Materials and methods

Samples

A total of 30 UHT flavored milk samples from various brands were randomly collected from supermarkets in Karaj, Alborz province, Iran, in October 2013. All samples were transported to the laboratory refrigerator and stored at 4 oC and analyzed for determining the presence of AFM1 before their expiry date.

Chemicals and regents

AFM1 standard was obtained from Sigma Chemical Co. Aflatoxin test immunoaffinity columns were purchased from VICAM (Watertown, MA, USA). Acetonitrile HPLC grade was purchased from Merck Co (Darmstadt, Germany). The stock solution of AFM1 was prepared in acetonitrile at a concentration of 0.5 μg mL-1 and was kept at −20 oC. Working standard solutions were prepared by stock standard solution diluting acetonitrile stock solution at concentrations ranging from 0.05 to 1.5 μg mL-1.

Extraction procedure and clean up by Immunoaffinity Column Chromatography

The AFM1 extraction procedure from milk samples was carried out according to the official method of Institute of Standards and Industrial Research of Iran (10). 60 mL from each sample was warmed at 37 oC and centrifuged at 2500 rpm and the upper fat layer was removed completely. 20 mL from skimmed milk passed through an immunoaffinity column at the flow rate of 2 mL min−1. The column was washed with 10 mL of water and the sorbent bed was dried and the AFM1 bound to the antibody was eluted with 2.5 mL of acetonitrile in 2 mL min-1 rate. The solution was evaporated under nitrogen gas and the residue was dissolved in 1 mL of mobile phase. 20 µL aliquot was injected into the HPLC equipment.

Quantitative Analysis by HPLC

The HPLC chromatograph (Waters, Milford, MA, USA) equipped with fluorescence detector (Waters,) was used to determine AFM1. The chromatographic separation was achieved on a reversed phase C18 column (Waters Spherisorb, 5 µm particle size, 250 mm, 4.6 mm I.D.), at an ambient temperature. The excitation and emission wavelengths were set at 360 and 440 nm, respectively. Standard solutions of AFM1 with concentrations of 0.05, 0.25, 0.5, 0.75, 1, 1.25, 1.5 μg mL -1 in acetonitrile were used to obtain the calibration curve.

Acetonitrile/methanol/water (ratio 2:2:4 v/v) was used as the mobile phase at the flow rate of 1 mL/min. AFM1 peak in the chromatogram was identified by comparing its retention time with that of the analyzed AFM1 standard under the same conditions. The peak was quantified from the area under the curve of sample chromatogram by using the equation of calibration curve (y = 401810 +33125, R2 = 0.996). The retention time for AFM1 was 5.8 min. The limits of detection and quantitation were 0.015 and 0.018 μg/L, respectively.

Recovery test was performed by spiking aflatoxin into milk samples (0.05 µg/L). Mean recovery rates was 83.3% and relative standard deviations was equal to 1.8%.

Statistical analysis

All statistical analyses were performed using SPSS software (Version 16; SPSS Inc., Chicago, IL) and the data were expressed as Mean ± Standard deviation (SD).

Results and Discussion

The occurrence and the distributions levels of AFM1 concentration in UHT flavoured milk samples are presented in Table 1. The concentration of AFM1 in all samples was lower than the ISIRI and FDA limit of 0.5 μg/L (11-12). But, 10 (33.3%) of UHT flavored milk samples contained higher levels than maximum limit of 0.05 µg/L of the European Union (13).

Table 1

Occurrence and level of AFM1 in UHT flavored milk in Iran

Analysed samples	Positive samples(%)	Frequency distribution (%) (µg/L)					Range (µg/L) a	Average b (µg/L)
		<LOQ	LOQ- 0.05	0.05- 0.1	0.1- 0.5	> 0.5
30	30 (100)	5 (16.7 %)	15 (50 %)	4 (13.3 %)	6 (20 %)	0	<LOQ – 0.14	0.079 ± 0.032

Min – Max.

Mean of positive samples ± SD.

Among aflatoxins, AFM1 is the most important for health for many consumers especially for children. Several surveys of aflatoxin M1 contamination in raw milk and milk products are reported in the other studies (1). As can be seen in Table 2. several researchers in Iran and other countries (8,9,14-21) reported the incidence of AFM1 contamination only in UHT milk but not the flavored milk. Our findings showed a high incidence of AFM1 in UHT flavoured milk samples. Kabak and Ozbey (17) reported less AFM1 (20%) at detectable levels in UHT milk samples; but in a recent study, Temamogullari and Kanici (22) determined AFM1 in 100% of the surveyed UHT milk samples from Turkey. In previous studies conducted in Iran by ELISA method, Movassagh Ghazani (23) showed that 100% (100 of 100) UHT milk samples were contaminated with AFM1 in Tabriz and 66.66% had levels above the EU limit. A study from India Siddappa et al. (24) reported AFM1 in UHT milk in 29 out of 45 samples (64.4%), ranging from 0.06 to 0.7 µg/L and within the positive samples 29 (100% of the total) were above the EU limit. In a previous survey by Shundo et al. (25) from Brazil by HPLC method, reported that 40 (100%) samples of 40 UHT milk samples had higher concentration of AFM1 and one sample was higher than the EU maximum limit of 0.05 µg/L, which is similar to our results. Furthermore, in Brazil, 42 UHT milk samples were screened for aflatoxin contamination and 34 (80.9%) samples contained AFM1. The aflatoxin of UHT milk was in the range of 0.02–0.26 µg/L (26). In another study conducted in Turkey by Aydemir Atasever et al. (27) identified UHT milk samples that were contaminated with aflatoxin M1. On the other hand, they were reported that 150 UHT milk samples collected in Erzurum, 59% (89 samples) were positive for aflatoxin M1 at levels of 0.05-0.185 µg/L, also 16 (10.7%) samples exceeded the maximum tolerable limit of the European Community and the Turkish Food Codex. In the present study, there was a high incidence by 33.3% of analysed raw milk samples exceed the maximum limit for AFM1 (0.05 µg/L) set by EU regulations and also none of samples was not above ISIRI that is similar previous studies in Brazilian by Shundo and Sabini (26), Shundo et al. (25) and Silva et al. (28). The previous study by Santini et al. (29) from Sicily-Italy showed that 5 (41.7%) UHT milk samples was contaminated with aflatoxin M1 and also none of samples was not to above 0.05 µg/L according to EU, but our results was higher than this result.

Table 2

Occurrence and levels of AFM1 in UHT milks reported in previous studies

Country	Sample	Positive (%)	Range (µg/L)	No> 0.05 (µg/L) (%)	Method	Reference
Iran	109	62.3	0.0464-0.01	17.4	ELISA	Fallah (8)
Iran	210	55.2	<0.002-0.005	33.3	ELISA	Heshmati and Milani (9)
Turkey	129	58.1	0–0.54364	47	ELISA	Unusan (14)
Turkey	100	67	0.01-0.63	31	ELISA	Tekinsen and Eken (15)
Iran	49	100	>0.017-0.1	95.3	ELISA	Movassagh (16)
Turkey	40	20	0.004-0.076	5	HPLC	Kabak and Ozbey (17)
China	153	54.9	0.006-0.16	20.3	ELISA	Zheng et al (18)
Brazil	75	30.7	1-4.1	NR	HPLC	Oliveira et al (19)
Pakistan	84	41.6	LOD-0.88	25	HPLC	Iqbal et al (20)
Croatia	706	NR	0.00398-0.1835	9.64	ELISA	Bilandzic et al (21)

NR- Not reported

Conclusion

This study was the first to report AFM1 contamination in UHT flavoured milk samples in Iran. Although none of the samples did not exceed the ISIRI limit (0.5 µg/L) but all of them were contaminated with AFM1. Hence, this is a warning for governmental agencies to inform farmers and dairy factories about health consequences of aflatoxins. However, concerns about aflatoxin M1 in milk and dairy products are common for consumers of all age groups especially for infants and children because they are the largest consumers.