Redesigning the process of laparoscopic sleeve gastrectomy based on risk analysis resulted in 100 consecutive procedures without complications.

INTRODUCTION: In recent years, laparoscopic sleeve gastrectomy (LSG) is becoming increasingly popular. The quite simple technique, lack of anastomoses, fully stapling course of the resection and the laparoscopic approach influence the attractiveness of the procedure from the surgeon's perspective. Though the feasibility of LSG is appreciated, the range of complications seems to be considerable. AIM: To prospectively evaluate modification of the bariatric process in LSG patients.
MATERIAL AND METHODS: The initial results of the first series of LSG patients (G1) were unacceptable and led to redefinition, based on risk analysis, of the entire bariatric process. A number of corrective and preventive actions were implemented into the process. The impact of innovations on the outcomes of the next 100 LSGs (G2) was assessed. Complications, intraoperative difficulties and postoperative adverse events were registered.
RESULTS: The total complication rate of the G1 group was 32% (8/25 patients). When several corrective and preventive actions were implemented in the subsequent process, there were no postoperative complications observed in the G2 group. Sixteen intraoperative difficulties were encountered in group G2 but resolved intraoperatively and did not affect the postoperative course.
CONCLUSIONS: The systemic approach to the LSG procedure by innovating the entire process significantly reduced the rate of complications. The 'learning curve' should not be limited only to the manual operative training. Preventive actions based on risk analysis should be considered as the core component in redesigning the process.

Introduction

In the last decade, a distinct trend in the approach to restrictive procedures can be observed in bariatric surgery [1]. Laparoscopic sleeve gastrectomy (LSG) is currently displacing the previously dominant position of vertical banded gastroplasty (VBG), laparoscopic adjustable gastric banding (LAGB) or even proximal laparoscopic Roux-en-Y gastric bypass (LRYGB) [2, 3]. Since it has been observed that the impact on weight loss after LSG is surprisingly higher than it could result from restriction alone, the number of procedures is rapidly growing [4].

Sleeve gastrectomy initially constituted a first-step operation to achieve substantial weight loss prior to the more advanced malabsorptive surgery. It has been demonstrated [5-9] that this strategy reduces the risk of post-operative morbidity and mortality in over 50 kg/m2 body mass index (BMI) individuals. Some of the patients after LSG quite unexpectedly show satisfactory weight loss without a second-step procedure and accept the mass gain, particularly when the resolution of obesity-associated morbidity is experienced [10]. Therefore the rate of complementary surgery seems to be much lower than primarily intended [11]. It could also be recognized as one of the reasons why LSG started to be performed as the sole procedure for individuals with varied BMI.

The hormonal interference via limitation of ghrelin secretion following LSG intensifies the restrictive effect on metabolic improvement [12, 13]. Additionally, the value of the procedure is enhanced by its exceptional feasibility. The relatively simple operative technique, lack of anastomoses, fully stapling course of resection and laparoscopic approach make the operation attractive from the surgeon's point of view and encourage more frequent choice of this solution [3, 14].

However, the increasing popularity of LSG carries the concern of postoperative complications associated with the procedure, whose frequency is variable among the published data [15]. The mortality range is from 0% to 1.5% and the post-operative morbidity extends even above 20% after LSG [16]. Weiner et al. reported the higher surgical risk of LSG than LRYGB [3].

The most common LSG complications are: bleeding from the staple line, bleeding from the divided gastro-splenic or gastro-colonic ligament, leak, anatomical or functional stricture of the sleeve, intra-abdominal abscess, bleeding to the digestive tract, splenic or hepatic injury, wound infection, trocar site hernia, pancreatitis, and pulmonary embolism [15].

It is generally known from the operators’ opinions that the repeatable sequences of the operation do not always lead to desirable results and some of the adverse events’ sources seem to be beyond the surgeon's control. Such independent factors cannot be improved only by surgical technical training but sometimes require changing the details in other parts of the process.

In the Department of General, Endocrine and Transplant Surgery of the Medical University of Gdansk, implementing the new procedure of LSG into the bariatric spectrum has been assessed as unacceptable. The high complication rate (32%) led to suspension of bariatric activity and forced a redefinition of the entire process to improve patients’ safety. The team focused on risk analysis, as the most important aspect of the planned change, targeted at the reduction of complications. The effectiveness of the modifications of the LSG strategy has been demonstrated in the study.

Aim

The aim of the study was to assess the impact of implemented innovations in separate parts of the process of laparoscopic sleeve gastrectomy on postoperative morbidity.

Material and methods

The prospective study, evaluating the impact of the innovated (after the unsatisfactory postoperative course of the initial 25 cases – group G1) LSG process on the early postoperative outcomes, was started in September 2009 and finished after 100 procedures in September 2012.

The complications and other adverse events in the G1 group and the way of their treatment are shown in Table I.

Table I

G1 complications and the way of their treatment

Complication	Treatment
Bleeding from staple line*	Reoperation at postop. day 1. Staple line oversewing
Bleeding from the gastro-splenic ligament*	Reoperation at postop. day 1. Additional clips
Naso-gastric tube entrapment in the staple line	Reoperation at postop. day 1. Removing the tube under laparoscopy control. Additional simple suture of the sleeve
Sleeve stenosis	Endoscopic dilatation at postop. day 30. Reoperation (RYGB) 6 months later
Intra-abdominal bleeding*	Continuing the drainage up to 7th postoperative day. Transfusion of 2 blood units
Intra-abdominal bleeding*	Continuing the drainage up to 5th postoperative day
Intra-abdominal bleeding, hematoma, abscess*	Continuing the drainage up to 7th postoperative day. Antibiotic therapy 30 days
Pancreatitis	Intensive conservative treatment
Aborted procedure due to restricted operative area exposure (enlarged steatotic liver)	Ultra-low-caloric diet (liver shrinking diet). Reoperation (LSG) 3 months later after weight reduction
Aborted procedure due to restricted operative area exposure (enlarged steatotic liver, abundant intraabdominal fat)	Endoscopic intra-gastric balloon for 6 months. Reoperation (LSG) 8 months later after weight reduction

“bleeding” has been treated as a complication when more than 200 ml of blood was collected in total

The criteria for patients’ eligibility for bariatric surgery were in accordance with the guidelines of the International Federation for the Surgery of Obesity and Metabolic Disorders [17].

Laparoscopic sleeve gastrectomy, as a bridge operation to further bariatric surgery, was planned for 48 (G1 – 9, G2 – 39) patients with BMI above 50 kg/ m2 (range 51–72 kg/m2). The indication for the definitive procedure, in 77 cases (G1 – 16, G2 – 61), was BMI between 35 kg/m2 and 50 kg/m2.

Patients with BMI 35-50 kg/m2, with type 2 diabetes (T2DM), gastro-esophageal reflux (GER), sweet or binge eaters, and those previously inefficiently treated with restrictive methods, were persuaded to undergo gastric bypass.

In both groups, the preoperative period, after the initial qualification, included: adequate blood tests, chest X-ray, abdominal ultrasound, upper GI endoscopy, endocrine evaluation, and 3 months nutritional and psychological preparation. In group G2 patients were obligated to lose at least 10% of the body weight during the preparation period. Additionally, G2 patients should keep on an ultra-low caloric (600 kcal) and low carbohydrate but rich in protein diet longer than in the G1 group (14 days vs. 7 days) before surgery to reduce the size of steatotic liver and gastro-colonic and gastro-splenic ligament fat.

Patients received prophylactic fractioned heparin for 12 h and one intravenous dose of antibiotic 30 min prior to the operation.

The last 100 LSGs have been performed by a fixed operative team (surgical and anaesthesiological). The accumulation of a few LSG procedures in one operative session and designating the operation room (OR) for bariatric surgery were provided in order to improve the process quality.

The LSG technique was standardized and depends on the purpose of the operation. When a definitive procedure was planned, the resection of the greater curvature was extended and the preparation of the gastro-colonic ligament started 2 cm from the pylorus and was continued to the angle of His close to the stomach edge. In super obese patients, the lesser sac was entered 6 cm from the pylorus to preserve part of the antrum.

In the G2 group, the 10 mm vessel sealing laparoscopic instrument was favored over the harmonic scalpel in skeletonizing the greater curvature, because of the larger coagulating surface of the jaws. The posterior stomach wall was liberated from the adhesions.

The number and sort of used linear-cutter device cartridges varied depending on the type of LSG.

For stapling the antrum in sole intentive LSG, one 60-mm green reticulated cartridge (4.8 mm staple height) of linear stapler was used in all patients. Regularly, 4–5 60-mm blue straight cartridges (3.5 mm staple height) sufficed to complete the stomach resection in G2. Previously, in group G1, the first 2 cartridges were green.

In the bridge procedure in group G2, usually 4–5 60-mm blue cartridges were used for stapling the stomach. We stopped using higher staples (green) because of the sleeve margin bleeding observed in G1 patients.

Initially (G1), the sleeve was fashioned over a 30 F gastric tube but in subsequent cases (G2) the thicker 38 F bougie was used for calibration.

To provide the proper hemostasis, the border of the resection, in bleeding places, was clipped. Bleeding staple line over-sewing was not routinely done in G1 but was recommended in G2 patients. In the G2 group unidirectional thread 3.0 was used for reinforcement of the staple line.

The methylene blue test was obligatorily performed after removal of the calibration tube and clamping the pylorus.

A liquid diet was given for all patients for the first week, followed by soft protein-rich food for another 4 weeks.

Patients were followed up for 30 days after LSG to detect early unwanted effects of the operation. The visits were then continued 3, 6, 12 months and every year postoperatively to monitor the metabolic results of the treatment.

The characteristics of the patients of groups G1 and G2 are detailed in Table II.

Table II

Characteristics of G1 and G2 patients

	G1 N = 25	G2 N = 100	t-Test
Preoperative characteristics
Intention sole/bridge (ratio)	16/9 (1.8)	61/39	NS
Mean age (range) [years]	42.4 (22–64)	44.2 (19–65)	NS
Male/female (ratio)	8/17 (0.47)	33/67 (0.49)	NS
Mean BMI (range) [kg/m2]	49.8 (36–71)	48.1 (35–68)	NS
Mean weight (range) [kg]	144.8 (98–189)	147.5 (97–180)	NS
Diabetes	3 (12%)	10 (10%)	NS
Hypertension	18 (72%)	73 (73%)	NS
Sleep apnea	7 (28%)	27 (27%)	NS
Degenerative joint disease	10 (40%)	43 (43%)	NS
Dyslipidemia	9 (36%)	38 (38%)	NS
Gastroesophageal reflux (GER)	3 (12%)	11 (11%)	NS
Mean weight loss in preparation period [%]	3.4	11.8	p < 0.05
Mean duration of liver shrinking diet prior to LSG [day]	5.4	14.4	p < 0.05
Previous intragastric balloon	1 (4%)	3 (3%)	NS
Previous gastric banding	1 (4%)	2 (2%)	NS
Intraoperative characteristics
Average operative time (range) [min]	122 (55–180)	71 (45–125)	p < 0.05
Calibration tube [F]	30	38
Average blood loss (range) [ml]	208 (10–990)	64 (10–100)	p < 0.05
Position	Anti-Trendelenburg	Semi-sitting
Reinforcement of staple line	Not routine	Recommended when bleeding
Hemostatic tool	Harmonic scalpel	Vessel sealing device
Fixed team	–	+
Designated OR	–	+
Cumulating the LSG procedures in series	–	+
Procedure abortion	2 (8%)	0
Intraoperative difficulties with no impact	Not registered	16 (16%)
on postoperative outcome
Complications	8 (32%)	0

Management of complications and risk analysis

The complications were managed based on the reputable quality management patterns established in points 8.5.2 (Corrective action) and 8.5.3 (Preventive action) of ISO 9001:2001 [18].

Definitions

Corrective action (CA) – activity undertaken after the analysis of a complication or other adverse event, addressed to the source of their occurrence, to prevent repeated onset.

Preventive action (PA) – activity undertaken as the result of risk analysis, addressed to the source of a potential complication or other adverse event, to prevent its manifestation.

The quality management system based on ISO 9001:2001 implemented in our institution required the following sequence of complications control: Each complication was reported, registered and examined during the routine clinical meetings. The most probable reasons were identified and the CAs were designed addressing the root causes of the problems. The solutions were implemented into the process map and became the routine clinical practice.

In parallel, the bariatric section analyzed the potentially intraoperative difficulties that could result in poor postoperative outcome. To minimize the complication rate some feasible PAs were suggested and adopted in the clinical procedure.

To compare groups t-tests were used. Statistical significance was considered for p < 0.05.

The aim and the assumptions of the study were consistent with the requirements of the hospital quality management system ISO 9001:2001 and approved by the Authorized Representative of the Hospital Board.

Results

The analysis of the complications in the G1 group led to the identification of sources of adverse events and implementation of corrective and preventive actions in several parts of the entire process of LSG.

Bleeding and insufficient hemostatic care were recognized as the most common direct reasons for postoperative complications (5/8). In 4 cases, the surgeons did not reinforce the staple line with extra suturing but only clipped the bleeding vessels. In one case, identification of the bleeding source was unclear but one of the short gastric vessels was suspected. The investigation of these 5 cases revealed that operations were scheduled to be done in the first vacant OR and all were performed late in the afternoon when the previous operations had finished.

One patient developed acute edematous pancreatitis as the result of irritation of the pancreatic body by too close harmonic scalpel activation, while releasing the adhesions of the posterior gastric wall. One patient was re-hospitalized because of distal part sleeve stenosis 30 days after a sole-intentive operation. During LSG, the tube had been calibrated with a 30 F bougie and additionally the staple line had been reinforced too tightly with the continues suture.

Finally, the calibration tube's entrapment in the mechanically sutured stomach wall was the direct reason for the reoperation of one patient. The poor cooperation with the anesthesiologist in correcting the bougie position was responsible for the error in this case.

In two cases, poor preoperative preparation of super obese and super-super obese patients led to bad exposure of the stomach because of the extremely large left lobe of the liver and abundant intra-abdominal fat, which resulted in untimely termination of the procedure.

A list of G1 complications and dedicated CA to prevent similar events is shown in Table III.

Table III

Management of complications in G1

Complication/adverse event	Direct reason	Root cause	Corrective action	Result in G2
Aborted procedure	Restricted operative area exposure because of enlarged steatotic liver and abundant intra-abdominal fat	Insufficient preoperative preparation period Hasty qualification Inadequate supervision of the qualification for the LSG procedure	Tightening the requirements of preoperative preparation period Mandatory weight reduction > 10% body weight. Liver shrinking diet – 14 days The decision of qualification for LSG procedure depends on official bariatric interdisciplinary team position	No aborted procedures Reduction of average operative time Prolonged preoperative preparation period
Bleeding from the staple line	Inadequate hemostatic efforts.Resigning from over-sewing when it seemed to be effective	Late hours of the procedures’ performance Pressure on the operators to finish the procedure by another OR team Randomly assigned OR staff	Rescheduling the operation list Designating separate OR for bariatric service in specific terms Fixing and educating the bariatric team	Reduction of intra-operative blood loss No reoperations Increase of effectiveness of OR service Reduction of average operative time
Bleeding from the gastro-splenic ligament	Inadequate hemostatic efforts.Bleeding not detected during the procedure	Insufficient hemostatic tools Inadequate inspection of operative area	Harmonic scalpel replaced by vessel sealing device Inspection of operative area with lower (8 mm Hg) intra-abdominal CO2 pressure	Reduction of intraoperative blood loss Randomly assigned OR staff No reoperations
Calibration tube entrapment	Poor cooperation with anesthesiologist	Randomly assigned OR staff Engaged anesthesiologist not educated in bariatric specificity	Fixing and educating the bariatric team Improvement the coordination	No reoperations Reduction of average operative time
Pancreatitis	Irritation of the pancreatic body by harmonic scalpel activation while releasing the adhesions	Activation of the harmonic scalpel too close to the pancreatic surface	Exercising particular caution in activating energy emitting instruments in pancreatic contiguity	No more pancreatitis diagnosed
Sleeve stenosis	Too tight sleeve creation enhanced by over-sewing	Too narrow calibration tube	Change the calibration tube	No more stenosis observed Reduction of postoperative vomiting and GER episodes

There were no postoperative complications observed in the subsequent consecutive 100 LSG cases.

In the G2 group, 16 (16%) difficulties in 15 patients were experienced during the operative procedure, but intraoperatively managed did not influence the postoperative course. The direct reason for additional suturing in 10 patients was bleeding from the staple line uncontrolled by clips (in 6 of them the bleeding was observed in the place where a green cartridge had been applied) and the margin of the resection had to be sutured.

In 3 cases, the hepatic injury caused by the nail of the trocar had to be supplied with a hemostatic sponge. These three patients, as they testified postoperatively, followed a liver shrinking diet shorter than required and an enlarged liver was observed during the operations.

One procedure was disrupted by a defect of the cartridge that stuck in the stomach tissue after being fired. It was cut out and the stomach wall was immediately sutured manually with a negative methylene blue test result. This fact was reported to the stapler producer representative and the firm examined this event as its own production process nonconformity and managed according to its own quality management system.

In one patient both bleeding from the divided gastro-splenic ligament and a slight leak at the site of cartridge connection required additional efforts. The source of bleeding was localized and supplied by LigaSure. The small opening was closed with a single suture.

There were no conversions to an open procedure. The mean operative time was 122 min (range: 55–180 min) in group G1 and 71 min (range: 45–125 min) in G2. The average blood loss was significantly reduced from 208 (10–990) ml in group G1 to 64 (10–100) ml in G2.

The mean hospital stay was shortened from 6.5 days in group G1 to 3.2 in G2.

All patients reported for established follow-up visits up to 1 year after the procedure. Eleven percent of all 125 individuals (6 in G1, 8 in G2) who underwent LSG complained of vomiting episodes shortly after the operation, mainly because of dietary mistakes. In one case from the G1 group the reason was sleeve stricture.

Gastro-esophageal reflux symptoms were observed significantly more often in the G1 group and they corresponded to the diameter of the sleeve. Nine patients (36%) reported typical GER symptoms and required proton pump inhibitors, while GER in the G2 group was clinically diagnosed in 20% of cases.

The PA addressed to the potential adverse events have been detailed as process recommendations in Table IV and Figure 1.

Table IV

Preventive actions for G2 patients established as recommendations in the LSG process

Potential complication or adverse event	Preventive action		Area
Aborted operation due to abundant visceral fat and/or enlarged liver	Preoperative body weight reduction > 10%	1	Preoperative preparation program supervision
	Liver shrinking diet – 14 days	2
	Intra-gastric balloon when BMI > 70 kg/m2	3
	Final qualification dependent on team position	4
Operation process efficiency impairment	Cumulating the LSG procedures in designated OR	5	Bariatric procedures scheduling
	Fixed bariatric OR team	6
Liver injury during trocar insertion	Prolonged liver shrinking diet in super obese patients	7	Preoperative preparation program
	Semi-sitting position	8	Procedure initiation
	Insufflation by microlaparotomy	9
	Insertion the trocars under vision control after a full wall thickness notch (minimize the pushing pressure at time of insertion)	10
Bleeding from the gastro-colonic and gastro-splenic ligament	Application of advanced hemostatic tools with maximal clamp size	11	Operative equipment selection
	Suspending calibration tube placement to preserve flexibility of the stomach	12	Greater curvature mobilization
	Activating the ligation close to the greater curvature	13
	Avoiding tension during ligation	14
	Final inspection with abdominal CO2 pressure reduced to 8 mm Hg	15	Final procedure control
Stapler failure	Examination of the device before use (close-open-close)	16	Supervision of the suppliers
	Reporting the adverse events to the producer	17
Uncompleted fundus resection, segmental dilatation	Mobilizing the fundus by intensive release of adhesions up to left crura	18	Applying staplers
	Careful release of adhesions of posterior gastric wall up to lesser curvature vessels	19
	Spreading the stomach before stapling by grasping the greater curvature at site of short vessel stumps	20
	Firing the staplers as close to the calibration tube as possible	21
Staple line leakage	Use of green cartridge when first is applied close to the pylorus or last when banding was previous procedure	22	Applying staplers
	Arranging the staplers in one line without angulations between cartridges	23
	Firing the staplers without stomach tension	24
	Over-sewing the uneven staple line with omentum using unidirectional thread	25	Staple line reinforcement
	Additional suturing of the edge when intraoperative leakage detected	26
False negative result of methylene blue test	Naso-gastric tube placement under vision control	27	Final procedure control
	Methylene blue test after pylorus clamping with intra-sleeve pressure > 30 mm H2O	28
Staple line bleeding	Dalteparin sodium 5000 IU s.c. 12 h instead 1 h before surgery	29	Preoperative prophylactic
	Over-sewing the staple line when numerous sources of intra-operative oozing or bleeding detected	30	Staple line reinforcement
	Over-sewing staple line when green cartridges applied	31
	Over-sewing the staple line when relatively thin gastric wall observed	32
	Final inspection with reduced abdominal CO2 pressure	33	Final procedure control
Trocar site bleeding	Trocar sites inspection	34	Final procedure control
Tube entrapment	Proper cooperation with anesthesiologists during calibration tube manipulation	35	Cooperation with anesthesiologists
	Inserting the calibration tube under vision control just before staplers application	36
	Exposure of the tube position by palpating and flattening the gastric wall with the tool	37
Pancreatitis	Avoiding activation of energy emitting tools close to the pancreatic surface	38	Posterior wall mobilization
	Instead of intensive release of adhesions close to the pancreas, tighter sleeve over-sewing	39	Staple line reinforcement
GER	Patients with preoperative history of GER when < 50 kg/m2 BMI offered RYGB	40	Preoperative preparation program supervision
	Application calibration tube 38 F	41	Operative equipment selection
	No over-sewing if not necessary	42	Reinforcement of staple line
Stenosis	Application calibration tube 38 F	41	Operative equipment selection
	No over-sewing if not necessary	42	Staple line reinforcement
Trocar site hernia	Closing the defects post 12 mm trocars with surgical awl	43	Operative equipment selection
Vomiting	Application of calibration tube 38 F	41	Operative equipment selection
	Following dietary instructions	45	Postoperative care
Pulmonary embolism, deep venous thrombosis	Prolonged dalteparin sodium administration 1 × 5000 IU (4 weeks)	46	Postoperative care
	Fast patient mobilization (6 h post operation)	47

Figure 1

Map of the LSG process

Discussion

Laparoscopic sleeve gastrectomy is gaining popularity among obese patients and bariatric surgeons. The attractiveness of this procedure from operators’ perspective results from the seemingly undemanding technique. No anastomoses, fully stapled course of stomach resection, laparoscopic approach and unsophisticated surgical equipment requirements influence the relatively short ‘learning curve’ which has been defined for 30 cases while for LRYGB is established for even 100 operations [8]. Thus, the exceptional feasibility and the high demand for this well-tolerated, minimally invasive method tempt even less experienced bariatric surgeons to perform it more widely.

Nevertheless, the high pressure sleeve created with a long staple margin line, preceded by intensive division of fat-rich ligaments, seems to be conducive to increased risk of complications [19]. Even in high volume centers [15, 20–22], the rate of bleeding and leaks, which are considered as the main complications of LSG, impairs the safety of the bariatric service. Weiner et al. [3] reported more frequent occurrence of leaks after LSG than RYGB.

However, in our center, where the prevailing bariatric procedure is gastric bypass, we have not observed leaks in our LSG material. Intra- and postoperative bleeding was the dominant complication of sleeve gastrectomy. The risk of bleeding from the staple line can be managed with routine margin line reinforcement or using cartridges enriched in various hemostatic membranes [16]. The most convenient cartridge membranes multiply the total cost of the procedure and have not been accepted in our center also because of their non-confirmed influence on the potential leaks [16]. The over-sewing of the staple line has been described as a simple and sufficient maneuver but it does not unequivocally protect from leakage [3, 15].

Although a well-known, quite simple, very effective and cheap technique should be readily considered as the standard, it has not been implemented as a routine part of the procedure, not only in our center [15, 16].

To obtain the answer for that issue, a deeper analysis of the root cause of the problem was necessary. Neither the delicate surgical technique required, nor the unavailable laparoscopic instruments, but the time-consuming part of the almost finished operation, especially in the late afternoon period, was identified by our team as the true reason why this intraoperative preventive action was abandoned in most of the cases.

The change in organizing the bariatric service by scheduling the LSGs in one day in a designated operating room, enrolling an experienced team, was recognized as the key modification of the LSG process resulting in the series of 100 uncomplicated procedures. The important role of organizing the OR functioning and its influence on bariatric patients’ outcomes has been emphasized by Stepaniak et al. [23].

To encourage the operators additionally to secure the staple line, the unidirectional thread has been offered. This convenient device that eliminates the need for tying knots has been enthusiastically applied especially in G2 patients, with thin, proportionally to the staple height, stomach wall.

As has been reported previously by others [3, 16, 18, 24] and is observed in our own material, the reinforcement of the staple line can increase the rigidity of the created reservoir and can lead to higher frequency of gastroesophageal reflux disease (GERD) symptoms. Therefore the authors did not establish over-sewing as a mandatory injunction.

Moreover, our unpublished experimental study of tensile strength of resected stomach staple line demonstrated that leaks appeared in the places of cartridge joints at similar pressure (60–80 cm H2O) regardless of the presence and sort of reinforcement. The contrast outflow has been registered proportionally sooner when the angle between the sections of staples was acute. This phenomenon corresponds with the acknowledged recommendation to apply the staplers along the calibration tube in one line [16].

Bleeding from the fragile vessels, shrouded in surrounding fat, is specified as one of the frequent postoperative complications [15]. While the authors appreciate the value of the harmonic scalpel in laparoscopic procedures where the anastomoses are performed, the vessel sealing device gains an advantage over other advanced hemostatic tools in dividing thick gastric ligaments, through the size of its clamps.

Another innovation in the preoperative part of the process improved the LSG outcome. The more intensive preoperative patient preparation leading to loss of 10–15% body weight and ultra-low carbohydrate diet inducing liver downsizing [16] provided better exposure of the operating field and helped to avoid futile operations.

The ‘functional’ narrowing of too tight sleeve was observed in place of the angular incision of the stomach in several cases during contrast radiography. The extra tightened, by continuous suture of the resection margin, gastric tube intensified this trend. Postoperative reflux symptoms were significantly more frequently noticed in the G1 group where a thinner bougie was used for calibration. It has also been reported by other researchers [25, 26]. Thus, utilization of a 38 F calibration tube instead of 30 F could prevent sleeve stricture, particularly in sole intended LSG with longer greater curvature resection. In group G2, stenosis was not detected after LSG.

Instances of GERD were significantly rare in comparison with patients from the G1 group. The higher than 40 F fashioned sleeves, though suggested by other authors [16] as the optimal, manifest a trend to non-functional distention of the gastric tubes a few years after LSG and lead to weight regain [3, 25, 27].

Another complication that has been managed in this study, pancreatitis, is not commonly observed [15]. Investigating this adverse incident, the authors identified, as the most possible reason, activation of the harmonic scalpel too close to the pancreatic surface, while liberating the posterior stomach wall from the adhesions. To minimize the risk of pancreatic irritation, it has been recommended to prefer tighter over-sewing of the tube to achieve an adequate volume, than intensive and deep division of the adhesions in pancreas contiguity. Hyperamylasemia was never detected postoperatively in the subsequent 100 LSG.

It has been underlined in this study that systemic complications management influenced the outcome after subsequent LSGs. Concepts inspired by quality mechanisms successfully implemented in industry, based on the ISO 9001 norm, can guarantee continuous quality improvement also in medical service [28]. It was recognized as the most crucial effect of the learning curve, more important than only manual operative training.

The monitoring of intra-operatively treated complications which do not influence the short- and long-term postoperative course is not generally practiced [15] but could be a source of inspiration improving the overall proficiency of the process. In our routine practice, classifying intra-operative difficulties as nonconformities sharpened the criteria of defining what is adverse in the procedure. The risk analysis should be the core component in designing the process.

Several preventive actions like those demonstrated in the study and detailed in Table IV significantly reduced the number of unwanted events in our material of LSG.

Conclusions

The systemic approach to the bariatric procedure by innovating the entire process can significantly reduce the rate of complications and adverse events. The ‘learning curve’ should not be limited only to the manual operative training but also extend to each part of the procedure. Preventive actions based on risk analysis should be considered as the core component in redesigning the process.