Development and validation of a liquid chromatography/atmospheric pressure photoionization-tandem mass spectrometric method for the analysis of mycotoxins subjected to commission regulation (EC) No. 1881/2006 in cereals.

A sensitive and reliable liquid chromatography/photoionization (APPI) tandem mass spectrometry method has been developed for determining nine selected mycotoxins in wheat and maize samples. The analytes were chosen on the basis of the mycotoxins under EU Commission Regulation (EC) No. 1881/2006, i.e., deoxynivalenol (DON), zearalenone (ZON), aflatoxins (AFs), and ochratoxin A (OTA), and considering the possibility of a near future regulation for T-2 and HT-2 toxins. Mycotoxins were extracted from samples by means of an one-step solvent extraction without any cleanup. The developed multi-mycotoxin method permits simultaneous, simple, and rapid determination of several co-existing toxins separated in a single chromatographic run, in which AFs, T-2 and HT-2 toxin are acquired in positive, while OTA, DON and ZON in negative mode. Although a moderate signal suppression was noticeable, matrix effect did not give significant differences at p=0.05. Then, calibration in standard solution were used for quantitation. Based on the EU Commission Decision 2002/657/EC, the method was in-house validated in terms of ruggedness, specificity, linearity, trueness, within-laboratory reproducibility, decision limit (CCalpha) and detection capability (CCbeta). For all the analytes, the regression coefficient r ranged between 0.8752 (DON in wheat) and 0.9465 (ZON in maize), biases related to mean concentrations were from -13% to +12% of the nominal spiking level, and the overall within-laboratory reproducibility ranged 3-16%; finally, CCalpha values did not differ more than 20% and CCbeta not more than 42% from their respective maximum limit. Method quantification limits ranged from 1/20 (AFG1) to 1/4 (AFG2 and OTA) the maximum limit established by European Union in the Commission Regulation (EC) No. 1881/2006 and its subsequent amendments. Copyright 2010 Elsevier B.V. All rights reserved.