Nitritation and denitritation of ammonium-rich wastewater using fluidized-bed biofilm reactors.

Fluidized-bed biofilm nitritation and denitritation reactors (FBBNR and FBBDR) were operated to eliminate the high concentrations of nitrogen by nitritation and denitritation process. The dissolved oxygen (DO) concentration was varied from 1.5 to 2.5 g/m(3) at the top of the reactor throughout the experiment. NH(4)-N conversion and NO(2)-N accumulation in the nitritation reactor effluent was over 90 and 65%, respectively. The average NH(4)-N removal efficiency was 99.2 and 90.1% at the NLR of 0.9 and 1.2 kg NH(4)-N/m(3)day, respectively. Increasing the NLR from 1.1 to 1.2 kg NH(4)-N/m(3)day decreased the NH(4)-N elimination approximately two-fold while NH(4)-N conversion to NO(2)-N differences were negligible. The NO(2)-N/NO(x)-N ratios corresponded to 0.74, 0.73, 0.72, and 0.69, respectively, indicating the occurrence of partial nitrification. An average free ammonia concentration in the FBBNR was high enough to inhibit nitrite oxidizers selectively, and it seems to be a determining factor for NO(2)-N accumulation in the process. In the FBBDR, the NO(x)-N (NO(2)-N+NO(3)-N) concentrations supplied were between 227 and 330 mg N/l (NLR was between 0.08 and 0.4 kg/m(3)day) and the influent flow was increased as long as the total nitrogen removal was close to 90%. The NO(2)-N and NO(3)-N concentrations in the effluent were 3.0 and 0.9 mg/l at 0.08 kg/m(3)day loading rate. About 98% removal of NO(x)-N was achieved at the lowest NLR in the FBBDR. The FBBDR exhibited high nitrogen removal up to the NLR of 0.25 kg/m(3)day. The NO(x)-N effluent concentration never exceeded 15 mg/l. The total nitrogen removal efficiency in the FBBRs was higher than 93% at 21+/-1 degrees C.