Biological effects of rinsing morsellised bone grafts before and after impaction.

Rinsing bone grafts before or both before and after impaction might have different effects on the incorporation of the graft. Rinsing again after impaction might negatively influence bone induction if growth factors released by impaction are washed away. We studied if transforming growth factor-betas (TGF-betas) and bone morphogenetic proteins (BMPs) are released from the mineralised matrix by impaction and if these released growth factors induce osteogenic differentiation in human mesenchymal stem cells (hMSCs). Rinsed morsellised bone allografts were impacted in a cylinder and the escaping fluid was collected. The fluid was analysed for the presence of TGF-betas and BMPs, and the osteoinductive capacity was tested on hMSCs. Abundant TGF-beta was present in the fluid. No BMPs could be detected. Osteogenic differentiation of hMSCs was inhibited by the fluid. Results from our study leave us only able to speculate whether rinsing grafts again after impaction has a beneficial effect on the incorporation process or not.

Introduction

Bone impaction grafting with a cemented prostheses is a biologically attractive technique for treating bone stock defects around failed total hip prostheses, with long-term clinical survival data available both on the acetabular and the femoral sides [8, 21].

Although the technique on the acetabular side has been well described by the original promoters [22], a dispute has been raised about the pros and cons of rinsing the allograft bone chips. Both rinsing once (before) and twice (before and after) impaction are used. However, rinsing before impaction or before and after impaction might have quite different effects on the incorporation of the grafts.

Rinsing before impaction enhances the stability of graft reconstructions by creating a higher interparticle shear resistance [7]. Also, in more realistic acetabular testing models with bone impaction grafting, rinsing had a positive effect on the initial stability of the cemented cups [1, 25]. In addition, the use of allografts induces an immunogenic response to the graft. Since most antigenic cells are found in the marrow, rinsing the grafts to remove blood, marrow and fat have been shown to diminish this negative aspect [10]. Bone grafts rinsed before impaction are better incorporated compared to unrinsed allografts [27].

Rinsing again after impaction is performed, however, only on the acetabular side, in the expectation of an additional effect on the initial mechanical stability through an increase in cement penetration. Although clinically practised, there is no experimental data supporting the benefit of rinsing again after impaction. It is not known how the rinsing of morsellised bone grafts again after impaction affects the incorporation process. Rinsing the grafts again after impaction might have a negative effect on bone induction if growth factors released by impaction are washed away.

By the impaction procedure, many microfractures are created, and biologically active factors in the bone matrix are, consequently, released. Recently, it was shown that a physiologically significant amount of transforming growth factor-β (TGF-β) was released by the strong compression of rinsed cancellous bone blocks from femoral heads [9]. Many contradictory reports have been published on the effects of TGF-βs on bone formation [2, 12], however, the effects of TGF-βs on bone graft incorporation are unknown.

Furthermore, it is not known if, other, more potent stimulators of bone induction, like bone morphogenetic proteins (BMPs), are released in physiologically relevant concentrations from the mineralised matrix during impaction. Therefore, we studied if TGF-βs and BMPs are released in physiologically relevant concentrations from the mineralised bone matrix by firm impaction, and if these released growth factors induce osteogenic differentiation in human mesenchymal stem cells (hMSCs).

Materials and methods

Production of “impaction fluid”

Cancellous allografts were collected from five human femoral heads obtained from the authors’ institutional bone bank. Swabs were taken and tested for bacterial contamination. All specimens were clear of bacterial contamination. The allografts were cut to 5 × 5 × 5-mm pieces using a rongeur and were subsequently pooled. Blood and marrow were removed macroscopically by rinsing the grafts with saline for approximately 1 min, leaving only a white bone structure. Rinsing was done using a commercially available high-pressure pulsatile lavage system (SurgiLav® Plus, Stryker Nederland BV, Waardenburg, the Netherlands). The grafts were in a sieve during rinsing. Allografts were dried overnight in a laminar flow cabinet (sterile airflow) at 4°C.

The bone grafts were inserted into a cylinder with a diameter of 30 mm. A piston, slightly smaller in diameter, was inserted into this cylinder. A rubber ring, sealing the piston, prevented the escape of fluid between the piston and the wall of the cylinder. Using an MTS loading device (MTS Systems Corporation, Minneapolis, MN, USA), the allografts were impacted. Fluid was evacuated through a canal in the bottom of the cylinder and were collected sterile. The applied pressure was calculated to be 12.5 MPa. The gathered fluid was centrifuged for 10 min at 3,000 rpm at 4°C. Any cellular and fatty debris was separated from the supernatant. The supernatant was called “impaction fluid.”

Analysis of “impaction fluid”

TGF-β1 and TGF-β2 levels in the “impaction fluid” were measured by enzyme-linked immunosorbent assay (ELISA; Quantikine®, R&D Systems Europe Ltd., Abingdon, United Kingdom) according to the manufacturer’s instructions. The plate was read in an ELISA reader at 450 nm (Sunrise™, Tecan Group Ltd., Männedorf, Switzerland). Experiments were performed in triplicate.

The presence of BMPs was determined using a modified BMP-selective reporter bioassay (BRE-luc) inducing luciferase expression [16]. This assay is based on 3T3 fibroblasts stably transfected with the BRE-luc reporter construct. In short, 3T3 BRE-luc cells were seeded in a density of 20,000 per well in microtitre plates in D-MEM (Gibco Invitrogen Corp., Grand Island, NY, USA) with 5% FCS. After 24 h, BMP-containing samples were added and the cells were incubated for a further 20 h. Luciferase activity was quantified using the Bright-Glo™ Luciferase Assay System (Promega, Madison, WI, USA). Luminescence was measured using a plate luminometer according to the manufacturer’s protocol (POLARstar Galaxy, BMG Labtech GmbH, Offenburg, Germany). For the standard curve, serial dilutions of rhBMP-2 (R&D Systems Europe Ltd., Abingdon, United Kingdom) to final concentrations of 0 to 100 ng BMP-2/ml were used. The lower detection limit of this assay is 1.6 ng/ml BMP-2. Experiments were performed in triplicate.

Almost all members of the TGF-β family, including BMPs, are secreted as latent complexes and need to be activated to exhibit their biological activity [28]. Therefore, both active and total growth factor levels were measured in order to have an impression of latent growth factor levels. The total growth factor levels were measured by activating the growth factors in the samples using hydrochloric acid and, subsequently, neutralising the samples by sodium hydroxide, according to the manufacturer’s instructions.

Culture study

Human mesenchymal stem cells (Poietics™ hMSC, Cambrex Bio Science Verviers, S.p.r.l., Belgium) were cultured up to passage 7 on mesenchymal stem cell growth medium (MSCGM™ BulletKit® (PT-3001), Cambrex Bio Science Verviers, S.p.r.l., Belgium). The cells were incubated in a humidified atmosphere of 92.5% air and 7.5% CO2 at 37°C. After primary culture, cells were detached using trypsin/EDTA (Cambrex Bio Science Verviers, S.p.r.l., Belgium), and the cells were seeded in 96-well plates at a density of 20,000 cells/cm2. The cells were allowed to attach overnight. After cell attachment, the cells were cultured under static conditions for 7 days. Cells were cultured on osteogenic differentiation medium (hMSC Osteogenic Differentiation BulletKit® (PT-3002), Cambrex Bio Science Verviers, S.p.r.l., Belgium) with and without 10−7 M dexamethasone (Sigma, Chemical Co., St. Louis, MO, USA). The supernatant (“impaction fluid”) was lyophilised. Subsequently, the lyophilised “impaction fluid” was resuspended in osteogenic differentiation medium (without dexamethasone), equal to the original volume of the supernatant. The hMSCs were stimulated with 5 ng/ml TGF-β1 (rhTGF-β1, R&D Systems Europe Ltd., Abingdon, United Kingdom), 10−8 M vitamin D3 [1,25(OH)2D3], 100 ng/ml BMP-2 (rhBMP-2, R&D Systems Europe Ltd., Abingdon, United Kingdom) and 10%, 20%, 40% and 80% “impaction fluid.” The culture medium was changed every three days. Experiments were performed in triplicate. Osteogenic differentiation medium without dexamethasone was used as the negative control, whereas osteogenic differentiation medium supplemented with dexamethasone and vitamin D3 was used as the positive control [4].

Alkaline phosphatase assay

Alkaline phosphatase (ALP) activity was measured to obtain information about the osteogenic differentiation of the cells. Medium was removed and the cell layers were washed twice with phosphate buffer solution (PBS). The cells were fixed with 4% buffered formaldehyde and washed twice with PBS again.

The substrate solution was made by adding 1 ml of 10 mM MgCl2 to 10 ml of 1 M di-ethanol-amine (DEA) and dissolving 52.6 mg of para-nitrophenyl phosphate (PNPP) in 10 ml of this solution. Subsequently, 100 μl of substrate solution was added to each well and the plate was incubated for 15 min. The reaction was stopped by adding 100 μl of 0.5 M NaOH. The plate was read in an ELISA reader at 405 nm (Wallac™ VICTOR2 1420, PerkinElmer Life and Analytical Sciences, Inc., Boston, MA, USA).

Neutral red assay

A neutral red (NR) assay was performed to obtain an indication of the number of viable cells (proliferation). A 1:1 solution of neutral red stock (1 mg/ml milliQ water) and 1.8% NaCl solution was made and filtered. One hundred microlitres (100 μl) of this solution was added to each well and the plate was incubated for 90 min at 37°C. Neutral red solution was removed and the cell layers were washed twice with PBS. Subsequently, 100 μl of elution buffer (0.05 M NaH2PO4/50% EtOH) was added to each well. The plate was read in an ELISA reader at 550 nm (Wallac™ VICTOR2 1420, PerkinElmer Life and Analytical Sciences Inc., Boston, MA, USA). The neutral red assay was used to correct the alkaline phosphatase assay for the number of viable cells.

Results

Analysis of the “impaction fluid” revealed that TGF-β was abundant. Both TGF-β1 and TGF-β2 were present in the “impaction fluid” in physiologically significant amounts. The total levels of TGF-β1 and TGF-β2 present after activation were 5.39 (±1.12) ng/g bone and 1.20 (±0.12) ng/g bone, respectively. Before the samples were activated, an already active amount of 0.43 (±0.05) ng TGF-β1/g bone and 0.13 (±0.11) ng TGF-β2/g bone was measured (Fig. 1). No BMPs could be detected using the BMP-selective reporter bioassay. Luciferase expression did not exceed the detection limit of 1.6 ng BMP-2/ml.

Fig. 1

Level of transforming growth factor-β1 and -β2 (TGF-β1 and TGF-β2) measured in the “impaction fluid.” Both total and already active growth factor levels are shown. Data are mean±standard deviation (SD) of experiments performed in triplo

Cell culture study

Adding dexamethasone to the osteogenic differentiation medium caused an approximately three-fold increase in ALP activity. Vitamin D3 added to osteogenic differentiation medium supplemented with dexamethasone showed the highest induction of ALP activity, whereas the addition of 5 ng/ml TGF-β1 strongly suppressed the induction of ALP activity. The “impaction fluid” dose-dependently suppressed the ALP activity induced by dexamethasone (Fig. 2). Both 40% and 80% “impaction fluid” showed similar suppression to 5 ng/ml TGF-β1.

Fig. 2

Data from cell culture. Human mesenchymal stem cells (hMSCs) were cultured with and without dexamethasone. As a measure for osteogenic differentiation, alkaline phosphatase activity (ALP) was corrected for the number of viable cells (NR). Data are mean±SD of experiments performed in triplicate

Discussion

The fracture surface created by impaction could have a growth-promoting effect by enabling the release of growth factors. Rinsing morsellised bone grafts again after impaction, therefore, might have a negative effect on bone induction if growth factors released during impaction are washed out. In our study, we examined if TGF-β and BMPs are released from the mineralised matrix by impaction, and whether these released growth factors induce osteogenic differentiation in hMSCs.

Both TGF-β1 and TGF-β2 were abundantly present in “impaction fluid.” Corresponding to what is seen in demineralised bone, in our study, most TGF-β was present in a latent form. Bone grafts from five femoral heads were pooled to minimise variation to overcome possible bias. However, it should be noticed that a large variation of TGF-β exists in human bone tissue both in tissue location and between individuals [19]. Our results are in accordance with the results of Fyhrie et al. [9] who recently showed that strong mechanical compression of cancellous bone blocks from femoral heads accelerates the release of TGF-β2. In addition, they and others suggested that mechanical loading also might accelerate the release of other growth factors, like BMPs, from mineralised bone matrix [3, 9]. In our study, however, no BMPs could be detected. In the light of the overwhelming literature on BMPs in bone [23, 24], we have to conclude from this experiment that BMPs cannot be released from the mineralised matrix by impaction. The BMPs in bone are considered to be activated by demineralisation [26]; however, as described in Burwell’s classical work on bone grafting, some new bone formation may be induced also from non-demineralised allografts [5]. If all BMPs are retained in the bone, this might explain the coupling of resorption and new bone formation during the incorporation of morsellised cancellous bone in bone impaction grafting [20].

Since TGF-β is abundantly present in the “impaction fluid,” it is not surprising to see a suppression of osteogenic differentiation with an increasing concentration of “impaction fluid” in our culture experiment. TGF-β is known to inhibit the ALP expression of mesenchymal stem cells (MSCs), even when these cells are stimulated with BMPs [12, 17]. In contrast to BMPs, TGF-β is unable to induce osteogenesis in mesenchymal pluripotent cells [12, 14]. From this perspective, it seems that rinsing bone grafts again after impaction might even be beneficial if TGF-β is washed away.

Data from numerous in vitro experiments have demonstrated the role of TGF-β in every stage of bone formation [6, 12]. Despite conflicting results, most data support the following model [12]: TGF-β increases bone formation in vitro mainly by recruiting osteoblast progenitors and stimulating their proliferation, thus, expanding the pool of committed osteoblasts, in addition to promoting the early stages of differentiation (bone matrix production). On the other hand, it blocks later phases of differentiation and mineralisation. These later stages are regulated by other growth factors, like BMPs. In other words, TGF-β generally inhibits the mineralisation of the matrix it helps to produce.

However, TGF-β not only modulates bone formation, but it can also stimulate osteoclast recruitment, formation and function [11, 15]. Bone resorption is more detrimental for the outcome of impaction grafting than just suppression or lack of bone formation, because resorption may compromise implant fixation [13, 18]. In addition, little or no BMPs from bone can be released prior to demineralisation. Only biological remodelling might free these factors (BMPs) to stimulate bone formation. Therefore, removing the excess of TGF-β from bone grafts might be a useful procedure.

On the contrary, TGF-β released after impaction might, indeed, be beneficial at an early stage postoperatively when chemotactic and proliferative signals might be needed. Furthermore, TGF-β promotes the early stages of osteoblast differentiation. However, the fluid released by the impaction procedure in clinical surgery will, probably, only be in situ for a short period of time at the very early postoperative stage, when osteoblast differentiation is not relevant.

It should be noticed that results obtained in vitro are often not in line or even contradictory to in vivo observations. In vivo, the presence of other growth factors, cytokines and hormones in the bone environment and the environment itself determine the exact outcome of TGF-β function.

In summary, by rinsing morsellised bone grafts again after impaction, growth factors (TGF-βs) released during impaction are washed out. Although TGF-β appears to be a potent stimulator of chemotaxis and the proliferation of osteoblasts, but also of osteoclast recruitment, formation and bone resorption, more potent stimulators of bone formation (BMPs) are not released from a mineralised matrix during impaction. To our knowledge, there is only one study reporting in vivo data on the effects of rinsing and the impaction of morsellised bone grafts on bone ingrowth [27]. Rinsing before impaction increased bone ingrowth in the allograft group to approach that of autografts. However, rinsing after impaction did not additionally alter bone ingrowth. The results from our study, and the dual effects of TGF-β reported in the literature, leave us only able to speculate whether rinsing grafts again after impaction has a beneficial effect on the incorporation process.