Isolation and structural analysis of the cyclic fatty acid monomers formed from eicosapentaenoic and docosahexaenoic acids during fish oil deodorization.

Long-chain polyunsaturated fatty acids (LC-PUFAs) present in fish oils are thermolabile molecules. Among the degradation reactions encountered, thermal cyclization occurs during refining or other heat treatments. Numerous studies have been carried out in the past to quantify and determine the structures of cyclic fatty acid monomers (CFAMs) formed from oleic, linoleic and linolenic acids in heated vegetable oils. Recently, much attention have been given to LC-PUFAs due to their potential health benefits. However, data on quantification of CFAMs formed from these fatty acids, such as eicosapentaenoic acid (EPA, cis-5, cis-8, cis-11, cis-14, cis-17 20:5) and docosahexaenoic acid (DHA, cis-4, cis-7, cis-10, cis-13, cis-16, cis-19 22:6), the two main LC-PUFAs in fish oils, are scarce. In the present study, structural analyses of CFAMs formed from EPA and DHA during the deodorization of fish oil are presented. Fish oil sample was deodorized at 250 degrees C for 3 h under a pressure of 1.5 mbar in a laboratory deodorizer. The CFAMs formed during heat treatment of fish oil were isolated by a combination of saponification, esterification, urea fractionations and column chromatography. Structural analyses of C20- and C22-CFAMs were achieved by gas-chromatography electronic-ionization mass-spectrometry (GC-EI-MS) of their 4,4-dimethyloxazoline (DMOX) derivatives. We identified seven out of 13 possible structures of hydrogenated CFAMs formed from EPA, and nine out of 16 possible structures of CFAM formed from DHA. Major CFAMs from both EPA and DHA were cyclohexyl isomers. All possible cyclohexyl isomers were found but only nine out of 18 of the cyclopentyl isomers were present in concentration sufficient for identification. Chemical mechanisms involved in the formation of polyunsaturated LC-PUFAs have been investigated. The results have shown that general principle involved in the cyclization of LC-PUFAs is same as that for the thermal cyclization of oleic, linoleic and alpha-linolenic acids.