Content and relative bioavailability of phosphorus in distillers dried grains with solubles in chicks.

Total phosphorus analysis was performed on 20 samples of corn distillers dried grains with solubles (DDGS), and three experiments were conducted to determine the bioavailability of P in different samples of DDGS varying in Lys digestibility and heat processing (autoclaving). Relative bioavailability of P was estimated from tibia ash using the slope ratio method after chicks were fed a P-deficient corn-soybean meal diet supplemented with 0.05 or 0.10% P from KH2PO4 or supplemented with 2 levels of the test DDGS (7 to 25%). The mean total P value for the 20 DDGS samples was 0.73 +/- 0.04% (SD), with an average dry matter value of 88 +/- 0.8% (SD). In experiment 1, the bioavailability coefficient for P in a random sample of DDGS relative to KH2PO4 was 69%. In experiment 2, the relative bioavailabilities of P in low digestible Lys DDGS 1, low digestible Lys DDGS 2, and high digestible Lys DDGS 3 were 102, 82 and 75%, respectively (P < 0.05). For experiment 3, the P bioavailability coefficients for a light-colored nonautoclaved DDGS and the same DDGS autoclaved at 121 degrees C and 124 pKa were 75 and 87%, respectively (P < 0.05). Our results showed that the total P content of DDGS was similar to the 0.72% value reported by the NRC (1994), but the relative P bioavailability is higher than the value estimated from NRC (1994) based on table values for total and nonphytate P content. Our results also indicated that there is substantial variability in P bioavailability among different DDGS samples and suggest that increased heat processing may increase the bioavailability of P in DDGS.