Influence of NaCl content and cooling rate on outgrowth of Clostridium perfringens spores in cooked ham and beef.

The effect of NaCl concentration and cooling rate on the ability of Clostridium perfringens to grow from spore inocula was studied with the use of a process that simulates the industrial cooking and cooling of smoked boneless ham and beef roasts. NaCl was added to ground cooked hams A and B (which were commercially obtained) to obtain levels of 2.4, 3.1, 3.6, and 4.1% (wt/wt) and 2.8, 3.3, 3.8, and 4.3% (wt/wt), respectively, and to raw ground beef to obtain levels of 0, 1, 2, 3, and 4% (wt/wt). Ham C, a specially formulated, commercially prepared product, was supplemented with NaCl to obtain levels of 2.0, 2.5, 3.0, and 3.5%. The samples were inoculated with a three-strain mixture of C. perfringens spores to obtain concentrations of ca. 3 log10 CFU/g. Portions of meat (5 g each) were spread into thin layers (1 to 2 mm) in plastic bags, vacuum packaged, and stored at -40 degrees C. Thawed samples were heated at 75 degrees C for 20 min and subsequently cooled in a programmed water bath from 54.4 to < or = 8.5 degrees C in 15, 18, or 21 h. For the enumeration of C. perfringens, samples were plated on tryptose-sulfite-cycloserine agar and incubated in an anaerobic chamber at 37 degrees C for 48 h. Population densities for cooked ham and beef increased as cooling time increased, and NaCl exerted a strong inhibitory effect on the germination and outgrowth of C. perfringens. For beef, while 3% NaCl completely arrested growth, pathogen numbers increased by > or = 3, 5, and 5 log10 CFU/g in 15, 18, and 21 h, respectively, when the NaCl level was <2%. C. perfringens did not grow during cooling for 15, 18, or 21 h in ham samples containing > or = 3.1% NaCl. Results obtained in this study suggest that a 15-h cooling time for cooked ham, which is normally formulated to contain >2% NaCl, would yield an acceptable product (with an increase of <1 log10 CFU/g in the C. perfringens count); however, for beef containing <2% NaCl, C. perfringens populations may reach levels high enough to cause illness.