Acute health effects after accidental exposure to styrene from drinking water in Spain.

OBJECTIVES: We studied subjective health symptoms in a population accidentally exposed to high styrene concentrations in drinking tap water. The contamination occurred during the reparation of a water tank.
METHODS: Residents of 27 apartments in two buildings using the contaminated water were contacted. A questionnaire on subjective symptoms was administered to 84 out of 93 persons living in the apartments at the time of the accident. Styrene concentration was measured in samples of water collected two days after the accident. The means of exposure associated with appearance of symptoms were examined through case-control analyses.
RESULTS: Styrene in water reached concentrations up to 900 microg/L. Symptoms were reported by 46 persons (attack rate 55 %). The most frequent symptoms were irritation of the throat (26%), nose (19%), eyes (18%) and the skin (14%). General gastrointestinal symptoms were observed with 11% reporting abdominal pain and 7% diarrhea. The factors most strongly associated with symptoms were drinking tap water (OR = 7.8, 95% CI 1.3-48), exposure to vapors from the basement (OR = 10.4, 2.3-47) and eating foods prepared with tap water (OR = 8.6, 1.9-40). All residents in the ground floor reported symptoms.
CONCLUSIONS: This accidental contamination led to very high styrene concentrations in water and was related to a high prevalence of subjective symptoms of the eyes, respiratory tract and skin. Similar exposures have been described in workers but not in subjects exposed at their residence. Various gastrointestinal symptoms were also observed in this population probably due to a local irritative effect.

Introduction

On December 10, 1999, residents of a neighborhood at Castellón, NE Spain informed the local authorities that drinking tap water had a strong solvent-type smell and produced nausea and various other health symptoms when consumed. Drinking water was pumped to the apartments from a tank adjacent to a fire-protection water tank that was repaired and waterproofed some hours earlier (Figure 1). The reparation involved the application of Aropal FS1933, an unsaturated polyester resin based on styrene, and of fiberglass mats. The possibility of a contamination was suggested due to a communication in the air environment of the two tanks. In addition, to facilitate drying, a fan was used which forced vapors from the repaired tank to the drinking water tank. The odor was perceived on the same day of the reparation work, first at the the water tanks, the parking place and later in other parts of the buildings. Residents reported that a thin gelatinous layer could be seen on the water in the tank.

Figure 1

Floor plan of the water tanks in the basement of the building adjacent to the garage. The water tank that was repaired and where a fan was positioned to accelerate the drying the paint is marked as A. The drinking water tank that was contaminated with vapors from Tank A is marked as B. C indicates the water pump for Tank A. D indicates the water pump for Tank B. The continuous blue lines indicate the walls separating the tanks that at the time of the accident were not reaching the ceiling. The continuous red lines indicate the walls separating the tanks from the remaining building and from the water tanks. The black dotted lines indicate the windows installed after the accident to facilitate access to the water tanks. The arrows indicate the direction of the vapors from water tank A at the time of the accident.

Studies evaluating inhalation exposure have demonstrated that styrene is a strong irritant [1,2]. Eye, nose and throat irritation is common at exposure levels above 50 to 100 ppm but can also occur at levels of about 20 to 30 ppm [3]. At very high levels chronic bronchitis type symptoms and other respiratory symptoms appear. Multiple central and peripheral acute nervous system effects have been described at levels of about 100 ppm but some neurological symptoms and color vision impairment may also appear at much lower levels [4-6]. Effects on the liver (acute in animals, chronic in exposed workers), and the kidney and also genotoxic effects have been described at low levels [7,8]. In the past, the so called "styrene sickness" was described in workers heavily exposed to styrene including nausea and vomiting, loss of appetite, and general weakness.

To our knowledge there are no previous reports of an environmental styrene contamination of water leading to health symptoms. In drinking water supplies, styrene is usually either not detected or detected at levels below 1 μg/L [9]. We present the investigation following this accidental environmental exposure to styrene.

Methods

Symptoms were reported among occupants of 30 apartments in two neighboring buildings (Figure 2), all using the same drinking water tank (Figures 3,4,5). A 100% census sample was defined and contacted and residents of 27 apartments participated in the study. A self-reported questionnaire (Annex 1 – see table 5) was administered requesting information on socio-demographic factors, various subjective symptoms, and also a list of activities potentially related to individual exposure, such as drinking tap water, eating foods prepared with tap water, bathing or showering. Of the 93 persons living at the time of the accident in the apartments, 84 completed the questionnaire on day 4. Parents completed questionnaires for children less than 14 years (n= 26). Among subjects 44 were male and 40 were female, and the mean age was 29 years (range 8 months to 77 years).

Figure 2

The building where the accident occurred.

Figure 3

The garage and the door giving access to the water tanks (see Figure 1, floor plan)

Figure 4

View towards water tank A and water pump for this tank (see Figure 1, floor plan). The photo was taken after the water tanks were completely separated.

Figure 5

View towards water tank B and water pump for this tank (see Figure 1, floor plan). The photo was taken after the water tanks were completely separated.

Table 5

Name and Surname of the head of the family

Complete address and telephone ...

Each resident in the apartment should complete a separate questionnaire

Resident 1, Resident 2 etc.

Family relation (spouse, son etc)...

Age ...

Sex ...

1. Have you been present in the apartment during the 10, 11 or 12 of the current month? Yes/No

2. Did you drink tap water during those days? Yes/No

3. How many glasses of water do you usually drink per day? Number...

4. During those days did you use tap water to prepare food? Yes/No

5. During those days did you bathe or shower at home? Yes/No

6. During those days where you exposed to gases, vapors or fumes at home? Yes/No

7. Between the 10 and the 14th of this month did you suffer from:

a. Abdominal pain

b. Diarrhea

c. Nausea

d. Vomit

e. Fever

f. A feeling of bad taste in the mouth

g. Irritation in the pharynx

h. Skin eruption

i. Skin irritation

j. Nasal Irritation

k. Nasal secretion

l. Eye irritation

m. Perception of bad odors

8. Did you consult a medical doctor? Yes/No

9. If you had any symptoms how long did they last?

10. Do you have any allergies Yes/No

11. Any other observations? Specify

Annex 1. Questionnaire to be completed by the residents of the building.

Among 15 subjects who reported symptoms, a sample of urine was collected on day 5 for analysis of the two main metabolites of styrene, namely mandelic and phenylglyoxylic acids (MA and PGA respectively) and of creatinine. Measurement were performed by gas chromatography at an accredited laboratory in Barcelona

The residents collected tap water samples at the second day after the accident. A more systematic sampling was done after the third day by the local health authority. Samples were analyzed by gas chromatography/mass spectrometry.

The reparation work at the firewater tank involved the application of an unsaturated polyester resin based on styrene (Aropal FS1933), followed by a cap of fiberglass mats (MAT300) containing 35% fiberglass, and then by a white gel coat based on styrene that contained a low (4–6%) proportion of a paraffin.

The sources of exposure that were associated with the occurrence of symptoms were examined through case-control analyses (10). Cases were defined as those subjects having any symptom (n = 46, mean age 30 years, range 8 months to 77 years), and the remaining subjects were defined as controls (n = 38, mean age 27 years, range 8 months to 72 years). Unconditional logistic regression was used, adjusting for age, sex, and when appropriate housing characteristics. The STATA 3.1 statistical package was used [11].

Results

Water samples analyses indicated very high concentrations of styrene in samples collected during the second and the third day after the episode, with measured levels up to 900 μg/L (Table 1). Analyses did not identify contamination of the drinking water by glass fibres that could have been released from the reparation work. Low styrene levels in water were observed after day 4. Low levels were also found for agents such as toluene, and other dissolved hydrocarbons. MA and PGA were not detected in the urine samples collected at day 5. Results of bacteriological analyses in water were normal.

Table 1

Styrene and toluene concentrations (μg/L) in drinking water samples

Place	Day	Compound	Level (μg/L)
Apartment 1st floor	11 Dec	Styrene	905
		Toluene	7.5
Apartment 3rd floor	11 Dec	Styrene	779
		Toluene	6.6
Apartment 8th floor	12 Dec	Styrene	767
		Toluene	6.8
Apartment 4th floor	14 Dec	Styrene	<0.5
		Toluene	<0.5
Water tank	14 Dec	Styrene	0.6
		Toluene	0.5
Apartment 4t floor	17 Dec	Styrene	<0.5
		Toluene	<0.5

Symptoms were reported by 46 of the 84 persons interviewed (attack rate 54.8 %). The onset of symptoms was December 10 (Day 1) for 44 subjects and December 14 (Day 5) for 2 cases. The average duration of symptoms was 2.8 days with a standard deviation of 1.6 days. Physicians attended nine subjects and confirmed irritation type symptoms but none of the subjects were hospitalized. The most serious case was of one resident who developed acute conjunctivitis after opening the door leading to the tank and being exposed to the confined environment. Solvent type odors were perceived by 89% of the subjects and a bad taste in tap water by 61%. The most frequent symptoms (Table 2), were irritation of the throat (26%), eyes (18%) and the skin (14%). Around 10% of the subjects reported general gastrointestinal symptoms, particularly abdominal pain. Among the 26 children below 14 years of age, 11 reported symptoms incluing one of two infants. Distance from the source was one of the factors related to symptoms, with all residents in the ground floor reporting symptoms (Table 3), and lower percentages reported in higher floors (chi square for trend 13.43, p < 0.01).

Table 2

Prevalence of reported symptoms by the residents of the apartments using styrene contaminated water.

Symptoms	No.	Relative prevalence
Irritation, throat	22	26%
Irritation, nasal	16	19%
Irritation, eye	15	18%
Irritation, skin	12	14%
Nasal secretion	9	11%
Abdominal pain	9	11%
Diarrhea	6	7%
Nausea	6	7%
Skin eruption	5	6%
Fever	3	4%
Vomit	1	1%
Total with symptoms	46	55%
Total study population	84

Table 3

Prevalence of any reported symptom by apartment floor

	Floor
	Ground	1st	2nd	3–8th
Subjects with symptoms	10	5	6	15
Subjects without symptoms	0	3	7	28
Prevalence (%)	100%	63%	47%	35%

The factors most strongly associated with the occurrence of symptoms were drinking tap water (OR = 7.8), exposure to vapors from the basement (OR = 10.4) and eating foods prepared with tap water after the occurrence of the contamination (OR = 8.6). Other factors, such as bathing and showering, length of stay indoor after the contamination, were also associated although results were not statistically significant (Table 4).

Table 4

Exposure after the accident associated with occurrence of symptoms in the case-control analysis

Factors	Cases (n = 46)	Controls (n = 38)	Odds ratio*	95% confidence interval
Age (mean, range)	29.9, 8m-77yr	26.8, 8m-72yr	1.0	0.97–1.04
Sex (female/male)	23/23	17/21	1.3	0.4–4.2
Presence in the house between 10–13 December	42	32	1.9	0.2–24.3
Consumption of tap water	21	3	7.8	1.3–48.1
Consumption of food prepared with tap water	34	13	8.6	1.9–39.8
Shower/bath	41	24	1.6	0.4–7.7
Direct exposure to vapors from basement	34	18	10.4	2.3–47.4
Floor of the apartment (continuous)			0.7	0.5–0.96

* Odds ratios are adjusted for the other variables shown in the table

Cases consumed a larger quantity of tap water at home (mean = 0.72 L/day) compared to controls (mean = 0.42 L/day) but differences were not significant. Among the 26 children the two main risk factors were exposure to vapors and eating food prepared with tap water, although differences were not statistically significant.

Discussion

The accidental contamination of a drinking-water tank in Castellón led to levels of styrene in tap water that were 2 to 3 orders of magnitude higher compared to the levels usually measured in drinking water [9]. An increased prevalence of reversible health symptoms was observed in subjects using water from the contaminated tank. The close time relationship between the application of the styrene-based material and the occurrence of symptoms that can be induced by styrene in humans point to styrene as the most likely candidate for the occurrence of symptoms, although the possibility of the presence of other undisclosed contaminants cannot be entirely ruled out. The effects of styrene in humans has been studied in workers exposed to high concentrations of the solvent in air but there are no published data on subjects exposed in their residence as a consequence of water contamination. In addition to the irritative effects to the eye, skin and respiratory tract frequently reported in workers, various gastrointestinal type symptoms were observed in this population that ingested highly contaminated water.

The population involved in the accident was well defined, and the non-participation rate was low and unlikely to have modified the results. No comparison population was used, e.g., residents in neighboring buildings, and the relative increase of the prevalences is unknown. However, the prevalence of most symptoms appears high and very likely above background prevalence. The general household health survey of Spain [12] only includes information for wide categories of symptoms that do not exactly correspond to symptoms reported in this study. Problems in the throat, cough, simple cold or influenza that limited the free time activities during the last two weeks were reported by 2.8% of adults in Spain, headache by 2%, nausea or vomit by 0.9% and diarrhea or other intestinal problems by 0.4% [12].

Styrene is an environmental contaminant, and low doses have been reported in drinking water (usually 0.1–0.2 μg/l) and in some foods as beer and coffee (10–350 μg/kg) [9,13]. Styrene concentration in water measured in our study was about two to three orders of magnitude higher. The presence of high concentration of the solvent was clearly perceived by subjects. A thin gelatinous layer on the surface of water in the tanks due to the poor water solubility of styrene [14] was visible, and nearly all subjects perceived the odor. The taste threshold concentration in water is around 0.7 mg/L [15].

Given the very high levels measured in water, it could be expected that extensive exposure of the skin and the mucosa occurred. Levels of individual exposure after the accident are, however, unknown. Mandelic and phenyglyoxylic acids were not detected in the urine samples collected at day 5. Nevertheless, this is not surprising considering that in humans the kinetics of styrene is fast, with an excretion half-time of both metabolites that is about 5–10 hours [16,17].

The main symptoms described in the population examined are acute irritation to the eyes, nose, throat and skin. These effects are probably not related to systemic absorption, but mainly due to local contact. Usually, exposure to styrene is by inhalation and there are several studies on the kinetics of this solvent following inhalation exposure [17] while gastrointestinal tract exposure has not been studied in humans. Studies in animals (mainly rat and mouse) suggest that styrene is absorbed and rapidly metabolised following oral administration [1]. The presence of symptoms of the gastrointestinal tract, such as abdominal pain and diarrhea is not among complaints usually referred by workers, even if nausea is among symptoms included in the so-called "styrene sickness" [18]. Possibly, gastrointestinal symptoms should be considered related to the local irritant action of styrene in ingested water or foods. This is also suggested by the relation observed between symptoms and consumption of water and of food prepared with water.

The prevention measures applied should be aimed at avoiding further contact with styrene-contaminated drinking water until concentrations reached low levels. Exposure to styrene was high but was limited in time and it seems unlikely that long-term effects will occur following this accidental exposure. This accident was caused by a series of failures at various levels of control and the prevention of similar accidents requires a conjunct of measures. In the case of this residential building in a Spanish city, the drinking water tank was not isolated from the fire protection water tank, nor was it isolated from car emissions from the parking garage in the basement, nor completely isolated from possible animal contact. In the first place, the architects and constructor should not have designed and built the two communicating water tanks without adequate ventilation. Subsequently the municipality should have done a complete inspection for the building before permitting its reoccupancy. The company doing the repair was unaware of potential toxic effects of the chemicals applied, and measures should be taken to inform companies and workers on the potential toxicity of the materials used. Furthermore the type of products applied in construction and repair of drinking water tanks should be regulated and clearly labeled. Several state agencies regulate the procedures for the use of environmental contaminants and potentially toxic agents and should collaborate to inform about these risks and apply regulations. This accident highlights the precarious conditions for water safety administration in some residential areas in Spain.

Competing interests

None declared

Authors' contributions

AAP, JBB and JLVV carried out the field study, did the statistical analysis and participated in the manuscript preparation. JLAM and NFC did the laboratory analyses. FG and MK drafted the manuscript. All authors read and approved the final manuscript.

Pre-publication history

The pre-publication history for this paper can be accessed here: