B Y-P Moy1, J-H Tay, S-K Toh, Y Liu, S T-L Tay. 1. Environmental Engineering Research Centre, School of Civil and Environmental Engineering, Nanyang Technological University, Singapore.
Abstract
AIMS: The effect of high organic loading rate (OLR) on the physical characteristics of aerobic granules was studied. METHODS AND RESULTS: Two column-type sequential aerobic sludge blanket reactors were fed with either glucose or acetate as the main carbon source, and the OLR was gradually raised from 6 to 9, 12 and 15 kg chemical oxygen demand (COD) m(-3) d(-1). Glucose-fed granules could sustain the maximum OLR tested. At a low OLR, these granules exhibited a loose fluffy morphology dominated by filamentous bacteria. At higher OLRs, these granules became irregularly shaped, with folds, crevices and depressions. In contrast, acetate-fed granules had a compact spherical morphology at OLRs of 6 and 9 kg COD m(-3) d(-1), with better settling and strength characteristics than glucose-fed granules at similar OLRs. However, acetate-fed granules could not sustain high OLRs and disintegrated when the OLR reached 9 kg COD m(-3) d(-1). CONCLUSIONS: The compact regular microstructure of the acetate-fed granules appeared to limit mass transfer of nutrients at an OLR of 9 kg COD m(-3) d(-1). The looser filamentous microstructure of the glucose-fed granules and the subsequent irregular morphology delayed the onset of diffusion limitation and allowed significantly higher OLRs to be attained. SIGNIFICNACE AND IMPACT OF THE STUDY: High organic loading rates are possible with aerobic granules. This research would be helpful in the development of aerobic granule-based systems for high-strength wastewaters.
AIMS: The effect of high organic loading rate (OLR) on the physical characteristics of aerobic granules was studied. METHODS AND RESULTS: Two column-type sequential aerobic sludge blanket reactors were fed with either glucose or acetate as the main carbon source, and the OLR was gradually raised from 6 to 9, 12 and 15 kg chemical oxygen demand (COD) m(-3) d(-1). Glucose-fed granules could sustain the maximum OLR tested. At a low OLR, these granules exhibited a loose fluffy morphology dominated by filamentous bacteria. At higher OLRs, these granules became irregularly shaped, with folds, crevices and depressions. In contrast, acetate-fed granules had a compact spherical morphology at OLRs of 6 and 9 kg COD m(-3) d(-1), with better settling and strength characteristics than glucose-fed granules at similar OLRs. However, acetate-fed granules could not sustain high OLRs and disintegrated when the OLR reached 9 kg COD m(-3) d(-1). CONCLUSIONS: The compact regular microstructure of the acetate-fed granules appeared to limit mass transfer of nutrients at an OLR of 9 kg COD m(-3) d(-1). The looser filamentous microstructure of the glucose-fed granules and the subsequent irregular morphology delayed the onset of diffusion limitation and allowed significantly higher OLRs to be attained. SIGNIFICNACE AND IMPACT OF THE STUDY: High organic loading rates are possible with aerobic granules. This research would be helpful in the development of aerobic granule-based systems for high-strength wastewaters.
Authors: J P Bassin; M Pronk; G Muyzer; R Kleerebezem; M Dezotti; M C M van Loosdrecht Journal: Appl Environ Microbiol Date: 2011-09-16 Impact factor: 4.792
Authors: Pranita S Phatak; Saurabh Trivedi; Anurag Garg; Sudhir K Gupta; Suparna Mukherji Journal: Environ Sci Pollut Res Int Date: 2016-03-11 Impact factor: 4.223
Authors: David G Weissbrodt; Samuel Lochmatter; Sirous Ebrahimi; Pierre Rossi; Julien Maillard; Christof Holliger Journal: Front Microbiol Date: 2012-09-13 Impact factor: 5.640