In vivo evaluation of a novel porous hydroxyapatite to sustain osteogenesis of transplanted bone marrow-derived osteoblastic cells.

Biosynthetic bone grafts are considered to contain one or more of three critical components: osteoprogenitor cells, an osteoconductive matrix, and osteoinductive growth factors. The basic requirements of the scaffold material are biocompatibility, mechanical integrity, and osteoconductivity. A major design problem is satisfying these requirements with a single composite. In this study, we hypothesize that one composite that combines bone marrow-derived osteoblasts and a novel mechanical reinforced porous hydroxyapatite with good biocompatibility and osteoconductivity (HA/BMO) can reach these requirements. A novel sintered porous hydroxyapatite (HA) was prepared by the following procedures. The HA slurry was foamed by adding polyoxyethylenelaurylether (PEI) and mixing. The pores were fixed by crosslinking PEI with diepoxy compounds and the HA porous body was sintered at 1200 degrees C for 3 h. The HA sintered porous body had a high porosity (77%), and was completely interconnected. Average pore diameter was 500 microm and the interconnecting path 200 microm in diameter. The compressive (17 MPa) and three-point bending (7 MPa) strengths were high. For in vivo testing, the 2-week subcultured HA/BMO (+) composites were implanted into subcutaneous sites of syngeneic rats until 8 weeks after implantation. These implants were harvested at different time points and prepared for the biochemical analysis of alkaline phosphatase activity (ALP) and bone osteocalcin content (OCN), and histological analysis. ALP and OCN in the HA/BMO group were much higher than those in the HA without BMOs control group 1 week after implantation (p < 0.001). Light microscopy revealed mature bone formation in the HA/BMO composite 4 weeks after implantation. In the SEM study, mineralized collagenous extracellular matrix was noted in HA/BMO composite 2 weeks after implantation with numbers of active osteoblasts. We conclude that the composite of the novel HA and cultured BMOs has osteogenic ability in vivo. These results provide a basis for further studies on the use of this composite as an implant in orthopaedic surgery. Copyright 2001 John Wiley & Sons, Inc.