Comparison of one week 0900 h serum cortisol, low and standard dose synacthen tests with a 4 to 6 week insulin hypoglycaemia test after pituitary surgery in assessing HPA axis.

OBJECTIVE: To compare the use of 0900 h serum cortisol and both low and standard dose Synacthen tests, one week after pituitary surgery with an insulin hypoglycaemia test performed 4-6 weeks after surgery in assessing the integrity of the hypothalamic-pituitary-adrenal (HPA) axis.
DESIGN: 0900 h basal serum cortisol was measured on days 6 and 7 after pituitary surgery (24 h off replacement hydrocortisone) followed by a low dose Synacthen test (1 microg intravenously) on day 6 and a standard dose Synacthen test (250 microg intramuscularly) on day 7. Three to 5 weeks later an insulin hypoglycaemia test was performed on all patients. Both low and standard dose Synacthen tests were performed on control subjects using an identical protocol.
SUBJECTS: Forty-two patients (21 male, 21 female), median age 49 years (range 23-73) who had pituitary surgery (Cushing's disease excluded). One patient had undergone repeat surgery for residual tumour and was studied following each operation. Sixteen healthy normal volunteers, median age 37 years (range 21-55). MEASUREMENTS: Serum cortisol measured by radioimmunoassay.
RESULTS: Two standard deviations below the mean serum cortisol (logarithmic transformation) in the normal volunteers 30 minutes after low dose Synacthen (1 microg) was 496 nmol/l and after standard dose Synacthen (250 microg) was 504 nmol/l. A normal response was therefore taken as serum cortisol > 500 nmol/l at 30 minutes in both tests (using 496 and 504 nmol/l did not alter results). 0900 h serum cortisols 1 week after surgery were > 250 nmol/l in 31 patients and 29 of these had a normal response to hypoglycaemia (peak serum cortisol > 550 nmol/l). Of the remaining two patients, one had 0900 h serum cortisol on day 6 and 7 after surgery of 405 and 441 nmol/l with a peak serum cortisol response to hypoglycaemia of 451 nmol/l; the other patient had 0900 h serum cortisols of 416 and 251 nmol/l and a peak cortisol response to hypoglycaemia of 498 nmol/l. All eight patients who had a 0900 h serum cortisol < 100 nmol/l failed a subsequent insulin hypoglycaemia test. Seven discrepancies were noted between the low dose Synacthen test and the insulin hypoglycaemia test in the 41 patients who had both tests. In six of these, a subnormal response to low dose Synacthen was followed by a normal response to hypoglycaemia. Three discrepancies were noted between the standard dose Synacthen test and the insulin hypoglycaemia test in the 40 patients who had both tests. In all three cases a normal response to Synacthen was followed by a subnormal response to hypoglycaemia.
CONCLUSIONS: A 0900 h serum cortisol < 100 nmol/l (24 h off replacement hydrocortisone) indicated ACTH deficiency and need for lifelong steroid replacement. A 0900 h serum cortisol > 450 nmol/l one week after pituitary surgery is highly suggestive of a normal cortisol response to hypoglycaemia. A 0900 h serum cortisol between 250 and 450 nmol/l one week after pituitary surgery permits safe withdrawal of steroid therapy pending an insulin hypoglycaemia test 1 month after surgery. Patients with 0900 h serum cortisol between 100 and 250 nmol/l should continue replacement steroids until definitive testing. Low dose and standard dose Synacthen tests 1 week after pituitary surgery are unreliable and should not be used.