Effect of fatty acids on the permeation of melatonin across rat and pig skin in-vitro and on the transepidermal water loss in rats in-vivo.

Transdermal delivery of melatonin would be advantageous in the treatment of sleep disorders considering the short biological half-life of melatonin and its variable bioavailability via the oral route. This study looked at suitable penetration enhancers for the transdermal permeation of melatonin. The permeation of melatonin was enhanced by all saturated and unsaturated fatty acids across both rat and porcine skin. There was a parabolic relationship between the carbon chain length of saturated fatty acids and the enhancement of melatonin permeation across rat and porcine skin. For rat skin, the maximum flux was observed with undecanoic acid (45.33 microg cm(-2) h(-1)) which enhanced the flux of melatonin 8.6 times compared with the control, whereas lauric acid produced the maximum flux of melatonin (24.98 microg cm(-2) h(-1); 4-7 times) across porcine skin. An increase in the number of double bonds in cis-9-octadecanoic acid increased the flux of melatonin across rat skin. In contrast, with porcine skin, the flux of melatonin decreased as the number of double bonds increased, although the flux values were not statistically significant. Treatment of rats with undecanoic acid, oleic acid and linolenic acid for 3 h using Hill top chamber enhanced the transepidermal water loss significantly. The maximum transepidermal water loss was observed with undecanoic acid and linolenic acid among saturated and unsaturated fatty acids, respectively. Nonanoic acid and myristic acid did not cause a significant change in the transepidermal water loss. The enhancement effect of saturated fatty acids on the permeation of melatonin was dependent on the chain-length of the fatty acid in both rat and porcine skin. While an increase in the number of double bonds in the fatty acid increased the flux of melatonin in rat skin, no significant difference in the flux was observed with porcine skin. The permeation enhancement of melatonin by saturated and unsaturated fatty acids across rat skin was significantly higher than that of porcine skin. A positive correlation was observed between the permeation enhancement effect of the fatty acids across rat skin in-vitro and the transepidermal water loss in rats in-vivo, suggesting that there is a similarity in the mechanism by which fatty acids enhance the permeation of melatonin and in the enhancement of transepidermal water loss. We conclude that saturated fatty acids such as undecanoic acid or lauric acid which showed maximum permeation across rat and porcine skin, respectively, may be used as potential penetration enhancers in the development of a transdermal delivery system for melatonin.